Adgas Emergency Response Procedures

Published on May 2016 | Categories: Documents | Downloads: 24 | Comments: 0 | Views: 253
of 106
Download PDF   Embed   Report

Comments

Content

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

CONTENTS

PAGE

SECTION

1.

DISTRIBUTION LIST
Révision request form
REVISION RECORD
INTRODUCTION

7
7
9
10

2.
3.

OBJECTIVE
SCOPE

10
10

4.

DEFINITIONS

10

5.

POLICY STATEMENT

12

6.

GUIDE TO THE MANUAL

12

6.1

RESPONSIBILITY FOR THE MANUAL

12

6.2

TRAINING

13

6.3

DRILLS
6.3.1 Introduction
6.3.2 Mini-Exercise
6.3.3 Major Exercise
6.3.4 Crew Award
6.3.5 Follow up

13
13
13
14
14
14

6.4

CONTRACTORS

14

6.5

REVISIONS
6.5.1 Revision request by ERPM holders
6.5.2 Review of Revision Request
6.5.3 Types of Revisions
6.5.4 ERPM Update

14
14
14
14
15

7.

ORGANISATION
7.1

Doc. Number

:

Network Loc.

:

COMMUNICATIONS
7.1.1 Radio Communication
7.1.2 Group Alert Personnel
7.1.3 Marshalling points
7.1.4 Important Emergency Telephone Numbers
7.1.5 Pager and Siren Test
7.1.6 Alarm Tones
7.1.7 Identification of Personnel
7.1.8 Communication of Incidents to Local Authorities
DAS/12/25

Prepared By
Directory Name

:

16
16
17
17
17
18
18
19
19

HSED

Approved By

: PM

HSEERP-0

Page No

:2

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

7.1.9
7.2

:

Network Loc.

:

Date: 15.05.08

Accident & Incident Investigation

19

EMERGENCY ORGANISATION
7.2.1 a Organisation
7.2.1 b Das Emergency Plan Manning Requirements
7.2.1 Table 1a Emergency Manning Matrix
7.2.1 Table 1b Weekly Duty Availability Roster
7.2.1 Table 1c Emergency Organisation
7.2.2 Responsibilities of Personnel

I
II
III
IV
V
VI
VII
VIII
IX
X
XI
XII
XIII
XIV
XV
XVI
XVII
XVIII
XIX
XX
XXI
XXII
XXIII
XXIV
XXV
XXVI
XXVII
XXVIII
XXIX
XXX
XXXI
XXXII
XXXIII
XXXIV
XXXV

Doc. Number

Rev. No. 0

DAS/12/25

20
20
20
21
22
23
24

Incident Commander
Operations section chief
Planning section Chief
Safety Officer
Liaison Information Office
Source Control Coordinator
Source Control Team Leaders
Finance & Administration Section Chief
Site Safety Officer
Perimeter Control Supervisor
Information Officer
On-Scene Commander
Technical Specialist Unit Leader
Human Resource Unit Leader
Supply Unit Leader
Communication Unit Team Leader
Shift Supervisor (CCB Power)
Process Shift Supervisor (CCB)
Head of Maintenance (P/U/S)
Operations Controller (S) {OC(S)}
Head of Storex
Operations Controller (P) {OC(P)}
Area Operator (utilities)
Emergency Services Liaison Operator
Operations Controller (U) {OC (U)}
Area Operator (Process)
Wardens
Senior Operator (Storex)
Operator: Sulphur Jetty
Operator: LNG jetty
Operator Storex
Duty Operations Safety Engineer
Shift Supervisor (S) {SS(S)}
Area Control Overhauls {AC (O)}
Steam Shift Supervisor (SSS)

Prepared By
Directory Name

:

25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59

HSED

Approved By

: PM

HSEERP-0

Page No

:3

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

8.

Date: 15.05.08

LOCATION EMERGENCY INSTRUCTIONS
8.1
8.2
8.3

8.4

8.5
8.6

8.7
8.8
8.9
8.10
8.11
8.12
8.13
8.14
8.15
8.16
9.

Rev. No. 0

SUPERVISOR’S RESPONSIBILITIES
EVACUATION OF LNG PLANT
CENTRAL CONTROL BUILDING (CCB)
8.3.1 H2S Alarm
8.3.2 Plant General Alarm
EVACUATION OF QUARRY MAINTENANCE BASE (QMB)
8.4.1 Personnel
8.4.2 Supervisor
EVACUATION OF STOREX
STOREX CONTROL ROOM
8.6.1 H2S Alarm
8.6.2 Evacuation
EVACUATION OF LNG JETTY
EVACUATION OF SULPHUR JETTY
EVACUATION OF LABORATORY
EVACUATION OF PROJECT BUILDING
EVACUATION OF AL JIMI ACCOMMODATION
EVACUATION OF OMO ANNEX
EVACUATION OF ADGAS MAIN OFFICE BUILDING
EVACUATION OF TRAINING CENTRE
EVACUATION OF CENTRAL WORKSHOPS
EVACUATION OF MATERIALS STORE

60
60
60
60
60
61
61
61
61
62
62
62
62
62
63
63
63
64
64
64
65
65

SPECIFIC EMERGENCY ACTIONS
9.1

MAJOR LEAK OF HC/ TOXIC GAS – LNG PLANT

66

9.2

OUTBREAK OF FIRE – LNG PLANT

68

9.3

MAJOR LEAK OF HC - STOREX

71

9.4

OUTBREAK OF FIRE - STOREX

73

9.5

MAJOR LEAK OF HC/ TOXIC GAS – LNG JETTY

75

9.6

OUTBREAK OF FIRE – LNG JETTY

78

9.7

PERSON FALLING INTO SEA – LNG JETTY

80

9.8

FIRE AT SULPHUR STORAGE/ JETTY

81

9.9

PERSON FALLING INTO SEA – SULPHUR JETTY

83

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEERP-0

Page No

:4

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

10.

Rev. No. 0
Date: 15.05.08

9.10

MAJOR INJURY OR ILLNESS

85

9.11

LOSS OF RADIOACTIVE SOURCE

86

9.12

QUARRY MAINTENANCE BASE EMERGENCY

87

9.13

DAS ISLAND POWER STATION – EMERGENCY RESPONSE
9.13.1 Outbreak of Fire
9.13.2 Gas or Oil Leak

89
89
90

9.14

SEA WATER LAYDOWN AREA

91

9.15

MAJOR LEAK OF LIQUID SULPHUR – LNG PLANT – PLANT 7

92

9.16

MAJOR LEAK OF LIQUID SULPHUR – RUNDOWN LINE

95

9.17

MAJOR LEAK OF LIQUID SULPHUR–SULPHUR STORAGE/JETTY 99

ABBREVIATIONS AND ACRONYMS

102

Attachments
1.

Area Designation and Marshalling Points.
DWG. No. 33-AOZ-0-3735

2.

Fire and Safety Equipment Symbols
DWG. No. 33-AOZ-0-3648

3.

Fire & Safety Equipment Location – Process and Utilities Areas
DWG. 33-AOZ-0-3613 – Sheet 1 Issue 4

4.

Fire & Safety Equipment Location – Blow down and Flare Areas
DWG. 33-AOZ-0-3613 – Sheet 2 Issue 2

5.

Fire & Safety Equipment Location – Storage Tanks (Existing)
DWG. 33-AOZ-0-3613 – Sheet 3 Issue 2

6.

Fire & Safety Equipment Location – LNG/LPG Storage Tanks (New)
DWG. 33-AOZ-0-3613 – Sheet 4 Issue 2

7.

Fire & Safety Equipment Location – Jetty Walkway and Jetty Head
DWG. 33-AOZ-0-3613 – Sheet 5 Issue 2

8.

Fire & Safety Equipment Location – Booster Compressors/ Maint. Base.
DWG. 33-AOZ-0-3613 – Sheet 6 Issue 3

9.

Fire & Safety Equipment Location – ADGAS Offices and Workshops
DWG. 33-AOZ-0-3613 – Sheet 7 Issue 0

10. General Layout of Fire fighting System Train 3
DWG. 39-A01-3-0001
Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEERP-0

Page No

:5

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

11. Fireman and Hydrant Locations (North Das Island)
DWG. 33-AOZ-0-3769
12. Sulphur Storage and jetty – fire fighting and potable water on/off shore P&I
distribution met work.
DWG. 28-D-A-62000

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEERP-0

Page No

:6

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

DISTRIBUTION LIST
GENERAL MANAGEMENT
COPY NO.
General Manager ...................................................................................... 001
Deputy General Manager ......................................................................... 002
Assistant General Manager (Technical) ................................................... 003
Assistant General Manager (Commercial) …………………..………….082
PRODUCTION DIVISION
Plant Manager........................................................................................... 010
Operations Manager ................................................................................. 011
Head of Process ........................................................................................ 012
Head of (Storex) ....................................................................................... 013
Head of Shift Operations .......................................................................... 014
Operational Controller (Process) - Train 1 & 2 ....................................... 015
Operational Controller (Utilities) - Train 1 & 2....................................... 016
Operational Controller (Storex)................................................................ 017
Area Controller (Process)......................................................................... 018
Area Controller (Overhauls)..................................................................... 019
Area Controller (Utilities) ........................................................................ 020
Operations Document Coordinator .......................................................... 021
Job Instructors .......................................................................................... 022
Operators Cabin Train 1........................................................................... 023
Operators Cabin Train 2........................................................................... 024
Amenities Block Train3 ........................................................................... 025
Maintenance Manager.............................................................................. 031
Head of Maintenance (P) ......................................................................... 033
Head of Maintenance (U)......................................................................... 034
Head of Maintenance (S) ......................................................................... 035
Site Supervisors (held in QMB)............................................................... 036
Head of Utilities ....................................................................................... 043
Head of Overhaul &Planning………………..………………………….. 032
Manager of General Technical Services………………………….………037
Instrument/Electrical Supervisor (CWS). ................................................ .038
Mechanical Supervisor (CWS) ................................................................ .039
Fabrication Supervisor (CWS)................................................................. .040
Rigging/Scaffolding Supervisor (CWS)………………………….………041
Senior Engineer - (General Services - CWS)…………………………….042
Head of Operations Engineering…………………………………………043
Senior Operations Engineer ……………………………………………...044
ENGINEERING DIVISION
Engineering Manager .............................................................................. .030
Head Of Mechanical & Structural Eng. (HM&SE)……………………….054
Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEERP-0

Page No

:7

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

PROJECTS DIVISION
Projects Division Manager..................................................................... 050
Head of projects ..................................................................................... 055
INTEGRITY & QUALITY DIVISION
Integrity & Quality Manager ................................................................. 070
Manager HSE ____
Senior Operations Safety Engineer ....................................................... 071
Safety Team Leader (Tech & Proj)........................................................ 072
Senior Health and Environment Engineer ............................................. 122
Operations Safety Engineer (OSE) ........................................................ 073
Health, Safety and Environment Engineer (Training) ........................... 074
Head of Product & Quality ................................................................... 052
Head of Corrosion and Inspection ......................................................... 053
Head of Performance & Reliability ...................................................... 053
HR Administration Das
Administration Manager (AMD)………………………………………080
HR Learning & Development
Head of Learning & Development (HL&D).......................................... 081
MATERIALS OPERATIONS DEPARTMENT
Head of Materials Operations ............................................................... 083
ADNOC E&P DIRECTORATE
E&P Director ......................................................................................... 090
ADMA-OPCO
Manager Das Asset ................................................................................ 103
Manager Das Operations ....................................................................... 100
Fire & Rescue Team Leader ................................................................. 102
Safety Engineer (Technical) .................................................................. 101
ADMA Safety ........................................................................................ 126
Incident commands centre ..................................................................... 104, 124
ADGAS HEAD OFFICE
Human Resources and Administration Manager ................................... 110
Manager of Public Relations.................................................................. 112
Head of Contracts .................................................................................. 084
Emergency Response Centre ................................................................. 125
SUPREME PETROLEUM COUNCIL
Director General Ministry of Petroleum 120
RESERVE.............................................................................................. 129
EH & S Division………………………………………………………. 091

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEERP-0

Page No

:8

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

REVISION RECORD
Date
15.5.08

Revision
Number
1

Doc. Number

:

Network Loc.

:

DAS/12/25

Page
Full Manual

Revision (Brief Description)
Full Manual Revised To Comply with ICS

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEERP-0

Page No

:9

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

1. INTRODUCTION
Prompt and effective emergency response reduces accidental losses and the consequences of
natural and man-made disasters. During an emergency there is not enough time to decide who
is in charge, what outside help is required and who needs to do what to control the emergency
situation. These issues must be addressed prior to the emergency.
An effective emergency plan assigns responsibilities to specific individuals, establishes
evacuation procedures, provides for notification to external agencies, establishes means of
communications and provides guidelines for critical specific emergency situations.
2. OBJECTIVE
The following are the main objectives of the ADGAS Emergency Response Procedures
Manual (ERPM)
To define the Emergency Organisation and the individuals functional role within the
organisation.
To provide clear and concise instructions to all Staff in the event of an emergency.
To consider some specific emergencies and outline individual guidelines for response.
3. SCOPE
This ERPM primarily applies to all Divisions/ Departments in ADGAS Das Island personnel
who have an assigned responsibility for handling an emergency within ADGAS area of
operation.
This ERPM gives a broad outline of individual’s responsibility during an emergency and
procedures for dealing with some specific emergencies.
This ERPM by no means covers all eventualities and SHOULD be considered only as a guide
and general source of information.
For emergency involving Crisis Management Team, refer to Crisis Management Plan.
For emergency involving ADMA-OPCO refer to the Facility Response Plan & ADMA-OPCOERPM
4. DEFINITIONS
The following terms have been used in this manual to define a condition or course of action:
SHALL
The word 'SHALL' expresses a mandatory requirement for a condition or course of
action.
SHOULD
The word 'SHOULD' expresses a strongly recommended or preferred condition or
course of action.
Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEERP-0

Page No

: 10

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

MAY
The word 'MAY' suggests a possible course of action or condition where other options
are available.
WARNING
A warning is used where failure to follow an instruction could result in serious injury or
major incident.
CAUTION
A caution is used where failure to follow an instruction could result in injury or
creation of a serious hazard.
NOTE
A note is used to draw attention to any matter of concern which may not be obvious, or
to a procedure which enables the job to be performed more safely or effectively.
BLUE ALERT
This is a minor emergency which can be contained and is unlikely to escalate. The
ADGAS Group Alert will not be activated.
YELLOW ALERT
This is an emergency which involves considerable hazard to personnel and/or plant
with the potential for escalation to a serious emergency situation.
The Plant or New Tank Farm siren may be actuated.
An ADGAS Group Alert is given in these circumstances and ADMA-OPCO is
informed.
For any emergency situation if the ADGAS Group Alert is activated, the alert status is
automatically considered to be “Yellow Alert”
RED ALERT
This is a serious emergency situation requiring the possible evacuation of all but
essential personnel from Das Island.
The Island sirens shall be actuated in these circumstances and an ADGAS Group Alert
given.
In the case of a red alert status, ADMA-OPCO Incident Controller becomes overall in
charge.
MINOR LEAK
A hydrocarbon leak which is within the resources of the Operations Shift
Superintendent (SS) to bring under control without calling for outside assistance, and
without danger of escalation.
MAJOR LEAK
A hydrocarbon leak which requires outside assistance to control and protect plant and
personnel, or is potentially uncontrollable.
Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEERP-0

Page No

: 11

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

WARDEN
Wardens are nominated for specific areas of the ADGAS facilities to control and direct
the assembly and evacuation of personnel to a safe Marshalling Point.
Designated Warden for each area are shown in the relevant Location Emergency
Instruction.
EMERGENCY SERVICES LIAISON OPERATOR (ESLO)
An Operator attending the Marshalling Point at which the Emergency Services are
assembling to act as the link between the Emergency Services and the Central Control
Building (CCB).
RELATIVE SAFETY
A position of relative safety is one in which, although exposed to potential hazard, the
risk is not immediate in nature.
INJURY
Injury is defined as an accident at work in which personal injuries are sustained.
MAJOR INJURY
A major injury is one in which the medical assistance is required on an urgent basis at
the accident location by members of the Clinic Staff.
MINOR INJURY
A minor injury is one in which treatment can be carried out by qualified medical
personnel at the hospital. Assistance from clinic staff is not required at the accident
location. This is classified as a first aid case.
RADIOLOGICAL PROTECTION SUPERVISOR (RPS)
A person appointed by the PM to exercise special supervision with regards to the
control and use of sources of ionising radiation.
5. POLICY STATEMENT
ADGAS HSEMS requires that Crisis Management Plans SHALL be in place and that all
potential emergency situations are identified assessed and have response plans which are
exercised regularly.
6. GUIDE TO THE ADGAS ERP MANUAL
6.1

RESPONSIBILITY FOR THE MANUAL
The Health, Safety, Environment Department (HSED) is the custodian of this manual
and is responsible for its maintenance and periodic upgrading. HSED will work closely
with divisional and departmental managers and designated manual holders and ICS
coordinator to ensure the following:
z

The establishment and promotion of procedures for maintaining the manual.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEERP-0

Page No

: 12

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

z

The co-ordination of revisions.

z

The distribution of revisions to manual holders.

Rev. No. 0
Date: 15.05.08

Manual holders are responsible for:

6.2

z

Keeping their copies updated by ensuring that all revisions are appropriately
inserted.

z

Studying all new material issued and incorporating it where relevant into their
work practices.

z

Suggesting changes and contributing new text material to improve the quality of
the manual.

z

Disseminating information contained in revisions.

z

Training personnel within their work area on applicable contents of the manual.



ICS Coordinator for updating the FRP to ensure the latest updated copy of
ADGAS ERP Manual is enclosed.

TRAINING
Formal training on the ERPM will be conducted as part of the primary safety induction
course for all new employees and employees being relocated to Das Island. For ICS
training refer to binder “A” FRP

6.3

DRILLS
6.3.1

Introduction
In order to test ADGAS employees understanding and adherence to the
ERPM, and also to prove the actual procedures themselves with a practical
demonstration of their efficiency or need for reappraisal, three types of
Emergency Drills are performed on a regular basis on the LNG Plant.
These are the Mini Exercise, the Major Exercise, and the Crew Award
Exercise.

6.3.2

Mini- Exercise
The Mini Exercise is designed to involve only Shift Operations Personnel, is
planned on a regular basis, and numbers around 20 exercises per year to give
all senior and junior crews equal participation. The Mini Exercise focuses on
a small scale emergency which is within the capability of the duty shift crew
to control, and does not require external assistance.

6.3.3

Major Exercise
The Major Exercise is designed to involve Shift Operations Personnel, all
ADGAS Group Alert Personnel, plus Das Island Fire Service (DIFS). It is

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEERP-0

Page No

: 13

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

planned on an irregular basis in order to inject the element of surprise, and
numbers at least three exercises per year, selecting a different senior crew and
a different scenario for each exercise.
6.3.4

Crew Award
The Crew Award Exercise is held once per year for each senior and junior
shift operations crew. It is designed to test individual and group knowledge of
Emergency Plans and Procedures, and practical first aid response to
emergency situations with regard to fire fighting, gas containment, Breathing
Apparatus (BA), rescue and resuscitation. The Crew Award Exercise is
intended to stimulate operator interest and participation in the on-going
practical training from HSED and DIFS.

6.3.5

6.4

6.5

Follow Up
Both mini and major exercises have a follow-up debriefing session, where
positive (and negative) actions are discussed, and positive recommendations to
improve procedures, equipment, response, or to identify areas for training are
made.
Important Note: It is required to give 24 hours notice to Critical National
Infrastructure Authority (CNIA), through ADGAS PO(R) for
all emergency exercises.
CONTRACTORS
Contractors involved in work activities on Das Island SHALL also be given a briefing
on the contents of the ERPM and SHALL, prior to starting work, be able to
demonstrate competency in understanding the relevant aspects of the contents and its
correct application.
REVISIONS
6.5.1
Revision request by ERPM holders
ERPM holders MAY initiate changes or add new text material by:
z
z
z

Completing a Revision Request form
Attaching the suggested text, graphics or photographs
Sending the form and new text to MHSE

6.5.2

Review of Revision Request
HSED SHALL acknowledge, review and consider all new material for
inclusion in the ERPM in consultation with ICS Coordinator. The originators
SHOULD be advised of the final outcome of the request. Approved material
SHALL be published as a revision or as a bulletin if the revision is urgent, to
be incorporated later into the ERPM.

6.5.3

Types of Revisions
HSED SHALL make required changes to the ERPM by issuing to manual
holders and FRP:
z
Normal revisions (on a periodical basis) and,
z
Bulletins (urgent revisions)

6.5.4

ERPM Update

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEERP-0

Page No

: 14

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

HSED together with division/department managers and ERPM holders and
ICS coordination SHALL periodically revise this manual as well as the FRP
by incorporating planned revisions with all current bulletins. When changes
are made, revision by pages will be issued. The new pages SHALL show the
revision change number and revision date.
The revised pages, accompanied by a cover letter signed by Manager of Health, Safety &
Environment (MHSE), briefly explaining the objective and purpose and its effective date of
implementation SHALL be distributed to all holders of the document.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEERP-0

Page No

: 15

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

Rev. No.0
Date: 15.05.08

ADGAS EMERGENCY RESPONSE PROCEDURES

7. ORGANISATION
7.1

COMMUNICATIONS
7.1.1

Radio Communication
In the event of an emergency being declared,
ALL PERSONNEL SHALL SWITCH TO CHANNEL ONE.
Radio communication SHOULD
INFORMATION ONLY.

be

restricted

to

ESSENTIAL

The Head of Shift Operations SHALL have priority on all radio
communications.
Fire & Rescue Team Das (FRT) SHOULD normally use their own radio
channel but MAY also have the facility to use the ADGAS channel.
An ADGAS radio, which has been issued to the FRT, SHALL be available at
the Forward Control for authorised users.
The fixed radio in the ICC are to be used for listen mode only unless under
adverse circumstances as directed by I incident Commander.

7.1.2

Group Alert Personnel
The following key personnel are on the Group Alert System:

Position

Pager No.

Plant Manager
Senior Operational Safety Engineer (SOSE)
Administration Manager (AMD)
Operations Manager
Head of Process
Maintenance Manager
Area Controller (Storex)
Lead Electrical Engineer (Utility)
Lead Instrument Engineer (Process)
Lead Mechanical Engineer (Process)
Head of Maintenance (U/P/S)
Operational Safety Engineer
Duty Operational Safety Engineer
Operations Resources Coordinator
Head of Shift Operations
Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

610
277
124
620
276
630
281
282
283
284
640
286
287
290
296

HSED

Approved By

: PM

ERPM-1

Page No

: 16

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

Rev. No.0

ADGAS EMERGENCY RESPONSE PROCEDURES

Personnel Officer (R)
Team Leader - Process Eng (TL{PE})
Head of Materials Operations
Senior Personnel Officer
Safety Technician

7.1.3

7.1.4

Date: 15.05.08

161
613
167
124
288

Marshalling Points
Marshalling Point No

Location

Tel: No.

M.P
M.P
M.P
M.P
M.P
M.P
M.P
M.P

Plant 26
QMB Car Park
Utilities Car Park
First St. East of Outstation 10
Base LNG Jetty
South Installation Control Room
South LNG/LPG Storex
South of Sulphur Storage

62011
62012
62013
62014
62015
62016
62017
62018

1
2
3
4
5
6
7
8

Important Emergency Telephone Numbers
Tel: No.
Abu Dhabi Emergency Crisis Centre
ADGAS Emergency
Das Emergency Control Centre
Clinic
Emergency Services Control Room
Fire Station
FRTL
Process Console Train I & II
Head of Shift Operations (HSO)
Operations Controller (Process)
Operations Controller (Utilities)
Storex Control Room
Power Shift Supervisor (LNG Plant)
LNG Jetty Control Cabin
LNG Jetty Ship's Telephone
Sulphur Jetty Control Cabin
Sulphur Jetty Ship's Phone
Train 3 Control Room (Process)
Train 3 Control Room (Utilities)
Incident Commander Centre
Safety Officer

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

65666/266088
62222
63661/68077
62500/63500
63333
63228/63400
63258
62113/62421/69130/62118
62118/69440
62127/62113
62117/62119
62582/62210
62258/62119/69330
62120
62229
62910
62910
62233/69022
62710/69033
68708
68709

HSED

Approved By

: PM

ERPM-1

Page No

: 17

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

7.1.5

Pager and Siren Test
The LNG Plant, Jetty sirens and Quarry Maintenance Base (QMB) Alarm,
along with ADGAS emergency vehicles sirens, are tested each Thursday
morning at 07.35 hrs.
The LNG Storex siren is tested each Thursday morning at 07:40 hrs.
ADMA-OPCO sirens are tested each Thursday morning at 07:30 hrs.
The pager systems for group alert personnel are tested daily except Friday at
07:40 hours.

7.1.6

Alarm Tones
LNG Plant
General Alarm: Intermittent wail, 7 seconds duration.
All Clear: Continuous wail.
Toxic Gas Detectors: Blue Flashing Lights.
Storex
General Alarm: Intermittent wail, 7 seconds duration.
All Clear: Continuou wail.
OMO Annexe Building
Bell.
Projects Building
Bell.
Workshops
Bell.
ADGAS New Office Building
Bell.
OMA Building
Bell
Quarry Maintenance Base
Air operated Klaxon.
Al Jimi Accommodation
Bell

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 18

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

7.1.7

Rev. No.0
Date: 15.05.08

Identification of Personnel
Key personnel SHALL be identified as follows:
Head of Shift Operations (HSO)
The HSO SHALL wear a white safety helmet with a 50mm red band.
Warden
Warden SHALL wear a bright yellow coloured jacket.
Emergency Services Liaison Operator (ESLO)
The ESLO SHALL wear orange arm bands.
Fire & Rescue Team Leader (FRTL)
The Fire and Rescue Team Leader (FRTL) SHALL wear a Fluorescent Red
Fire Helmet with a 38mm Silver Band.
Incident Controller
The Initial Source Controller, according to ICS SHALL wear a white safety
helmet with a 50 mm blue band.

7.1.8

Communication of Incidents to Local Authorities
The requirement for reporting of any incident to local authorities is covered in
detail in ADGAS HSE Manual Chapter 10 and this is generally within 24
hours to the various authorities. However, there is an exception regarding
fires of any magnitude e.g. full fire, a single flame, smouldering, or burning,
these must be reported immediately to the Critical National Infrastructure
Authority (CNIA). The mechanism for this reporting is through Head of Shift
Operations (HSO) to duty OSE who will inform the Personnel Officer
(Relations) who in turn will inform the CNIA of the event.
In the event of any fire, including late fire calls the Head of Shift Operations
(HSO) must call the duty OSE who will initiate the necessary reporting
through PO(R).

7.1.9

Accident & Incident Investigation
All accidents & incidents including fires, injuries, and environmental damage or
asset damage will be investigated by ADGAS through the Accident & Incident
reporting procedure to allow lessons to be learned and improvements to be
made. Only cases of suspected criminal damage will be handed to the police for
investigation. The Police and State Security will be kept informed of the
outcome of any ADGAS investigation into Reportable Accidents (see Chapter
10, Section 8).

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 19

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

7.2

Rev. No.0
Date: 15.05.08

EMERGENCY ORGANISATION
7.2.1(a) Organisation
The emergency organisation is shown on page no. 21 in Figure 1, and is
followed by a statement detailing the individual position's Location, Function,
Reporting Role, and Initial Response to plant emergencies.
In the event of loss of ICC, ADGAS Emergency Team will use Oasis Club.
7.2.1(b) Das Emergency Plan Manning Requirements
In order to have an effective operational emergency plan, emergency positions
are required to be filled at various locations on Das as defined in Fig. 1
Emergency Organisation. The Table 1a below does not cover every
emergency position, relating to ADGAS on Das, however it does provide the
arrangements for coverage of key day positions that are seen as essential for
operation of the emergency organisation. On the other hand Table 1b is used
by both HSED and ICS Coordinator on a weekly basis showing the availability
of each Emergency Response Team Member for the corresponding period.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 20

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

Rev. No.0
Date: 15.05.08

HSED

Approved By

: PM

ERPM-1

Page No

: 21

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

Rev. No.0
Date: 15.05.08

HSED

Approved By

: PM

ERPM-1

Page No

: 22

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

7.2.2 Responsibilities of Personnel
Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

24
:

HSED

Approved By

: PM

ERPM-1

Page No

: 23

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

I
II
III
IV
V
VI
VII
VIII
IX
X
XI
XII
XIII
XIV
XV
XVI
XVII
XVIII
XIX
XX
XXI
XXII
XXIII
XXIV
XXV
XXVI
XXVII
XXVIII
XXX
XXIX
XXXI
XXXIII
XXXIV
XXXV
XXXXVI

I.
Doc. Number

:

Network Loc.

:

Rev. No.0
Date: 15.05.08

Incident Commander
Operations section chief
Planning section Chief
Safety Officer
Liaison Information Office
Source Control Coordinator
Source Control Team Leaders
Finance & Administration Section Chief
Site Safety Officer
Perimeter Control Supervisor
Information Officer
On-Scene Commander
Technical Specialist Unit Leader
Human Resource Unit Leader
Supply Unit Leader
Communication Unit Team Leader
Shift Supervisor (CCB Power)
Process Shift Supervisor (CCB)
Head of Maintenance (P/U/S)
Operations Controller (S) {OC(S)}
Head of Storex
Operations Controller (P) {OC(P)}
Area Operator (utilities)
Emergency Services Liaison Operator
Operations Controller (U) {OC(U)}
Area Operator (Process)
Wardens
Senior Operator (Storex)
Operator: Sulphur Jetty
Operator: LNG jetty
Operator Storex
Duty Operations Safety Engineer
Shift Supervisor (S) {SS(S)}
Turnaround Team Leader
Steam Shift Supervisor (SSS)

25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59

INCIDENT COMMANDER
(PLANT MANAGER)

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 24

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

Location:
Incident Commander Centre (ICC).

Functions:
Ensures that Das Island Senior Management are fully informed of the
status of the particular emergency.
Co-ordinates any requirement for resources not directly controlled by
ADGAS.
In consultation with ADMA-OPCO Das Management participates in
decisions which, as a result of the incident, have a bearing on Das Island
generally.
Ensures Abu Dhabi based General Management are fully informed as to
the nature and implications of the emergency.
In consultation with HSO, Incident Controller and ADMA-OPCO Deputy
Incident Commander agrees to raise the alert status to “RED ALERT”.

Reports to:
General Manager.

Initial Response:
Reports to the ICC and establishes communications with the IC team.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 25

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

II. Operations section chief
(Operations Manager)

Location:
Incident Commander Centre (ICC)

Functions:
The Operations Section Chief, a member of the General Staff, is
responsible for managing all operations directly applicable to the primary
mission. The Operations Chief activates & supervises elements in
accordance with the Incident Action Plan & directs its execution; activates
& executes the Site Safety & Health Plan (SS&HP); directs the
preparation of unit operational plans, requests or releases resources, makes
expedient changes to the Incident Action Plan as necessary, & reports such
to the Incident Commander.

Report to:
Incident Commander

Initial Response:
On receipt of a Group Alert proceeds to the Incident Command Centre.
.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 26

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

III.

Rev. No.0
Date: 15.05.08

Planning section Chief
(Maintenance Manager

Location:
Incident Commander Centre (ICC)

Functions:
Responsible for supervising the work of Section personnel, & for
organizing & managing: the collection, evaluation, & display of
information about an incident, & the status of equipment & personnel
resources assigned to tactical response operations; the preparation of
Incident Action Plans for each operational period, the preparation of a
General Plan, if appropriate; the preparation of incident-specific plans; the
provision of a wide range of environmental services; the check-in &
assignment of Technical Specialists; the documentation of response
operations;
& the organization & management of demobilization operations.

Report to:
Incident Commander (IC)

Initial Response:
On receipt of a Group Alert proceeds to the Incident Command Centre.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 27

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

IV.

Rev. No.0
Date: 15.05.08

SAFETY OFFICER
(SENIOR OPS SAFETY ENGINEER)

Location:
ICC

Function:
Advises the ICC on the availability of the various Health, Safety and
Environment Division resources.
Assists the Incident Commander as required.
Contacts OSE in the Emergency Services Control Room. (ESCR)

Reports to:
Incident Commander.

Initial Response:
On receipt of a Group Alert proceeds to Incident Command Centre.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 28

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

V.

Rev. No.0
Date: 15.05.08

LIAISON INFORMATION OFFICER
PERSONAL OFFICER RELATION - PO(R)

Location:
Incident Commander Centre (ICC)

Functions:
Incidents that are multi-jurisdictional, or involve several agencies, may
require the establishment of the Liaison Officer position on the
Command Staff. The Liaison Officer is the point of contact for the
assisting & cooperating Agency Representatives & stakeholder groups.
Only one Liaison Officer will be assigned for each incident, including
incidents operating under Unified Command & multi-jurisdiction
incidents. The Liaison Officer may have assistants as necessary, & the
assistants may also represent assisting agencies or jurisdictions.
During emergencies (Act of Terrorism and threats not included) on Das
Island, the LIO will be the link between the local authorities, (including
Das Police), and the Das Island IMT.
In case of Act of Terrorism or threats to Das Island, the LC will be the
link between the local authorities and the IMT.
The LIO on Das Island will normally be the Senior Government
Relations Officer

Report to:
Incident Commander

Initial Response:
On receipt of a Group Alert proceeds to the Incident Command Centre.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 29

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

VI. SOURCE CONTROL COORDINATOR
HEAD OF PROCESS (HOP)/HEAD OF UTILITIES (HOU)

Location:
CCB or as advised by the HSO.
Function:
In conjunction with the OSC ensures that all appropriate procedures and
notifications have been carried out.
After incident review with HSO, coordinates appropriate procedures and
releases HSO to the incident scene.
Liaises with others in CCB as necessary.
Reports to:
Operations Section Chief (OM).
Initial Response:
On receipt of a Group Alert Signal, if the Marshalling Point has been
designated as either 1, 2 or 3 proceeds along the A1 direct to the CCB and
reports to the SS.
If Marshalling Point 4, 5, 6, 7 & 8 has been designated, proceeds to the
Marshalling Point indicated along the B1/ First Street and awaits
directions/ instructions from the Operations Controller

VII.
Doc. Number

:

Network Loc.

:

SOURCE CONTROL TEAM LEADER
(HEAD OF SHIFT OPERATIONS)

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 30

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

Location:
CCB initially then Incident Scene

Function:
Assumes full control of the situation and, in conjunction with the FRTL
declares Alert Status.
Directs all the resources available to him to ensures the incident is brought
under control as soon as possible with minimum risk to personnel and
plant.
In consultation with Incident Controller and the FRTL declares the "All
Clear".
As soon as informed of a yellow alert emergency situation in ADMAOPCO, activate the group alert of all ADGAS ICC Members.
To consult with FRTL, Incident Controller and both ADGAS & ADMAOPCO Emergency Team Leaders before declaring “RED ALERT” status.

Reports to:
Operations Section Chief (OSC).

Initial Response:
When informed of alarm, ensures that all essential notifications have been
made, makes initial assessment of the situation and declares Alert Status
in consultation
with FRTL.
Plant siren should be activated only when there is a life threatening
situation.

VIII. FINANCE & ADMINISTRATION SECTION CHIEF
(ADMINISTRATION MANAGER DAS)
Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 31

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

Location:
Incident commander centre (ICC).

Functions:
Responsible for supervising the work of section personnel & for organizing
& managing: the imposition of strict financial control procedures; the
provision of accounting services; the receipt & processing of claims; the
provision of financial/legal services & the Humane Resource
functions/requirements for incident personnel & their families.

Report to:
Incident Commander.

Initial Response:
On receipt of a Group Alert proceeds to the Incident Command Centre.

IX.

Doc. Number

:

Network Loc.

:

SITE SAFETY OFFICER
OPERATIONAL SAFETY ENGINEER (OSE)

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 32

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

Location:
Staging Area and as directed by the HSO.

Function:
Upon instructions from the HSO, to direct the HSED personnel at the site
of the incident and assist in fire fighting and search/rescue under the
instructions of the FRTL.

Reports to:
HSO/ FRTL/SO (ICC).

Initial Response:
On receipt of a Group Alert, or other alarm message, proceeds to the
Marshalling Point designated and then as directed by the HSO.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 33

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

X.

Rev. No.0
Date: 15.05.08

PERIMETER CONTROL SUPERVISOR
(SAFETY TECHNICIANS)

Location:
Staging Area and as directed by the OSE.

Function:
Provides assistance in fire fighting and search/rescue activities.

Reports to:
OSE

Initial Response:
Proceeds to designated Marshalling Point and then as instructed by the
OSE

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 34

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

XI.

Rev. No.0
Date: 15.05.08

INFORMATION OFFICER
(ICS COORDINATOR)

Location:
Incident Commander Centre (ICC)

Functions:
The Information Officer is responsible for developing & releasing
information about the incident to the news media, to incident personnel, &
to other appropriate agencies & organizations. Only one Information
Officer will be assigned for each incident, including incidents operating
under Unified Command & multi-jurisdictional incidents. The IO may
work with IOs from other directly involved response organizations to form
a Joint Information Center (JIC) when Unified Command has been
activated. When this occurs, one of the IOs becomes the Incident
Information Officer (IIO), & the others become assistants. The
Information Officer may have assistants as necessary, & the assistants
may also represent assisting agencies or jurisdictions. On Das Island, the
IO will release information (approved by the IC) to the Crisis
Management Team Only.

Report to:
Incident Commander (IC)

Initial Response:
On receipt of a Group Alert proceeds to the Incident Command Centre.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 35

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

XII.

Rev. No.0
Date: 15.05.08

ON-SCENE COMMANDER
FIRE RESCUE TEAM LEADER – FRTL

Location:
Staging Area /Site of incident.

Function:
Directs the resources of the DIFS to achieve the objectives determined by
the HSO. Responsible for fire fighting, gas control and search/rescue
activities.
Is responsible for initiating the call out to Emergency Teams of ADGAS
and ADMA-OPCO whenever an emergency escalates to yellow alert.
To consult with HSO and Incident Commander before declaring “RED
ALERT” status.

Reports to:
ESLO on arrival and subsequently to HSO.

Initial Response:

Doc. Number

:

Network Loc.

:

z

Proceeds to designated Marshalling Point where he assumes
responsibility for all fire fighting and search/rescue activities.

z

Establishes Forward Control in consultation with the HSO.

z

In consultation with the HSO establishes the approach to be taken in
controlling the emergency.

z

Acts within his discretion in all fire-fighting and search/rescue
activities.

z

Informs the ICC of Alert Status.

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 36

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

XIII.

Rev. No.0
Date: 15.05.08

TECHNICAL SPECILIAST UNIT LEADER
(PROCESS ENGINERING TEAM LEADER)

Location:
Incident Commander centre (IC)

Functions:
The Technical Specialist Unit Leader (TSUL) is the advisor to the IMT on
technical issues related to Process and Production within the specific OPCO
(ADMA-OPCO or ADGAS). The TSUL is supported by the Utility
Technical Specialist (UTS).

Report to:
Planning Section Chief (PSC)

Initial Response:
On receipt of a Group Alert proceeds to the Incident Command Centre.

.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 37

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

XIV.

Rev. No.0
Date: 15.05.08

HUMAN RESOURCES UNIT LEADER
SENIOR PERSONNEL OFFICER (SPO)

Location:
Incident Commander Centre (ICC)

Functions:
The Human Resource Unit Leader is responsible for providing direct human
resources services to the response organization, including ensuring
compliance with all labour-related laws & regulations.
Another important role for the HRUL is to provide human resources
services to personnel who is affected by the incident; for example critical
incident stress debriefings.

Report to:
Finance/Administration Section Chief (FASC)

Initial Response:
On receipt of a Group Alert proceeds to the Incident Command Centre.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 38

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

XV.

Rev. No.0
Date: 15.05.08

SUPPLY UNIT LEADER
HEAD OF MATERIALS OPERATIONS

Location:
Incident Commander Centre (ICC)

Functions:
The Supply Unit Leader reports directly to the Support Branch Director.
The Supply Unit Leader is responsible for ordering personnel, equipment
and supplies; receiving, and storing all supplies for the incident; maintaining
an inventory of supplies, and servicing non-expendable supplies and
equipment.

Reports to:
Logistics Section Chief (LSC)

Initial Response:
On receipt of a Group Alert proceeds to the Incident Command Centre.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 39

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

XVI.

Rev. No.0
Date: 15.05.08

COMMUNICATION UNIT LEADER
(TELECOM ENGINEER)

Location:
Incident Commander centre (ICC)
Functions:
The Communications Unit Leader, under the direction of the Service
Branch Director or Logistics Section Chief, is responsible for developing
plans for the effective use of incident communications equipment &
facilities; installing & testing communications equipment; supervising the
Incident Communications Center; distributing communications equipment
to incident personnel; & communications equipment maintenance & repair.
Report to:
Logistics Section Chief
Initial Response:
On receipt of a Group Alert proceeds to the Incident Command Centre.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 40

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XVII. SHIFT SUPERVISOR (CCB POWER)

Location:
Central Control Building.

Function:
To carry out notifications as laid down in Sec 9.0, Specific Emergency
actions.
To carry out the HSO or Head Of Utilities requests as related to the
electrical power systems following normal operational procedures.

Reports to:
HSO or Head of Utilities, whoever is in CCB.

Initial Response:
On receipt of an alarm carries out functions as specified in Sec 9.0.
Specific Emergency Actions.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 41

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

XVIII

Rev. No.0
Date: 15.05.08

PROCESS SHIFT SUPERVISOR (CCB)

Location:
Central Control Building.

Function:
To carry out notifications as laid down in Sec. 9.0 Specific Emergency
Actions.
To carry out the HOP or Head Of Utilities requests as related to the
control of Trains I, II and III and Utilities areas.

Reports to:
HSO or Head of Process, or whoever is in CCB.

Initial Response:
On receipt of an alarm carries out functions as specified in Sec 9.0
Specific Emergency Actions.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 42

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XIX HEAD OF MAINTENANCE (P/U/S)

Location:
Central Control Building.

Function:
To provide advice and assistance to the Head of Shift Operations (HSO),
Head of Process or Head of Utilities as required in all matters relating to
Plant Maintenance.

Reports to:
HSO, HOP or HOU, whoever is in CCB.

Initial Response:
On receipt of a Group Alert Signal, if the Marshalling Point has been
designated as either 1, 2 or 3 proceeds along the A1 direct to the CCB and
report to the HSO.
If Marshalling Point 4, 5, 6, 7 or 8 has been designated, proceeds to the
Marshalling Point indicated along the B1/ First Street and awaits
directions/ instructions from the Area Team Leader.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 43

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XX. OPERATION CONTROLLER STOREX
{OC(S)}

Location:
Site of incident (if in STOREX area)

Function:
To direct, on the instructions of the Head of Shift Operations (HSO), the
local resources available at the site of incident. Assumes the role of
Incident Controller.

Reports to:
Head of Shift Operations (HSO)

Initial Response:
On receipt of an alarm proceeds to the site after donning white safety
helmet with a 50 mm blue band. Carries out duties as Incident Controller
by co-ordinating first aid, fire fighting and search/rescue operations until
the arrival of the Fire Service who will then take the responsibility for fire
fighting and rescue activities. Acts to bring the emergency under control at
the direction of the HSO.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 44

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XXI. HEAD OF STOREX (HOS)

Location:
STOREX Control Room or as directed by Head of Shift Operations (HSO)
Function:
-

To advise and assist the HSO and HOP or HOU in matters relating to
storage and loading facilities under ADGAS control

-

To establish and maintain communication with vessel muster

Reports to:
HSO or HOP/HOU, whoever is in CCB
Initial Response:
On receipt of a Group Alert Signal, if the Marshalling Point has been
designated as either 1, 2 or 3 proceeds along the A1 direct to the CCB and
report to the Head of Shift Operations (HSO)
If Marshalling Point 4,5,6,7 or 8 has been designated, proceeds to the
Marshalling Point indicated along the B1/First Street and awaits directions/
instructions from the Area Team Leader.

XXII OPERATIONS CONTROLLER (PROCESS) [OC (P)]
Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 45

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

Location:
Site of incident (if in Train areas).

Function:
To direct, on the instructions of the HSO, the local resources available at
the site of incident. Assumes the role of Incident Controller.

Reports to:
HSO

Initial Response:
On receipt of an alarm proceeds to the site after donning white safety
helmet with a 50 mm blue band. Carries out duties as Incident Controller
by co-ordinating first aid, fire fighting and search/rescue operations until
the arrival of the Fire Service who will then take the responsibility for fire
fighting and rescue activities. Acts to bring the emergency under control
at the direction of the HSO.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 46

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XXIII AREA OPERATOR (UTILITIES)

Location:
On Site.

Function:
To report any incident and, under the direction of the OC (U) commence
appropriate shutdowns and isolations. Actively participates in the
search/rescue of casualties and initial fire and/or gas control until arrival
of the HSED/Fire Service to assume responsibility for these functions.

Reports to:
OC (U).

Initial Response:
Proceeds as instructed, to site of incident rendering assistance as required.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 47

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XXIV. EMERGENCY SERVICES LIAISON OPERATOR (PROCESS)

Location:
Site of incident/designated Marshalling Point.

Function:
To act as liaison between the Emergency Services and SS and, if
necessary, act as a guide to emergency vehicles.

Reports to:
OC (P)

Initial Response:
Puts on the bright colour arm bands and moves to designated Marshalling
Point to await Emergency Services.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 48

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

XXV.

Rev. No.0
Date: 15.05.08

OPERATIONS CONTROLLER (UTILITIES) (OC (U))

Location:
Site of incident (if in Utilities Area).

Function:
To direct, on the instructions of the HSO, the local resources available at
the site of incident. Assumes the role of Incident Controller.

Reports to:
HSO.

Initial Response:
On receipt of an alarm proceeds to the site donning white safety helmet
with a 50 mm blue band. Carries out duties as Incident Controller by coordinating first aid, fire fighting and search/ rescue operations until the
arrival of the Fire Service who will then take responsibility for fire
fighting and search/rescue activities. Acts to bring the emergency under
control at the direction of the HSO.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 49

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XXVI. AREA OPERATOR (PROCESS)

Location:
On Site.

Function:
To report any incident and, under the direction of the OC (P) commence
appropriate shutdowns and isolations. Actively participate in the
search/rescue of casualties and initial fire and/or gas control until arrival
of the HSED/Fire Service to assume responsibility for these functions.

Reports to:
OC (P).

Initial Response:
Proceeds as instructed, to site of incident rendering assistance as required.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 50

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XXVII. WARDENS

Location:
Wardens are assigned for various locations throughout the facilities as
required.

Function:
The function of the warden is to assemble personnel, leading them to the
safe Marshalling Point, ensuring that all rooms in the particular building
are empty, and carry out a head count.

Reports to:
HSO

Initial Response:
Proceeds to the assembly point as defined in Sec 8.0, Location Emergency
Instructions.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 51

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XV111 SENIOR OPERATOR (STOREX)

Location:
Storex Control Room
Function:
To carry out the HOS requests as related to the control of the Storex and
LNG/sulphur Jetties.
Reports to:
Head of Shift Operations (HSO)
Initial Response:
On receipt of an alarm caries out functions as detailed in sec 9.0,
Specific Emergency Actions.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 52

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XXIX . OPERATOR - SULPHUR JETTY

Location:
Sulphur Jetty

Function:
Informs the Storex Control Room (SCR) and CCB of an incident and
carries out initial notifications and shutdowns as detailed in Sec 9.0,
Specific Emergency Actions.

Reports to:
Shift Supervisor(S).

Initial Response:
Inform CCB and Storex Control Room (SCR). Also inform Berthing
Master if a vessel is at Berth.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 53

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XXX. OPERATOR - LNG JETTY

Location:
LNG Jetty

Function:
Informs the Storex Control Room (SCR) and CCB of an incident and
carries out initial notifications and shutdowns as detailed in Sec 9.0,
Specific Emergency Actions section.

Reports to:
OC(S)

Initial Response:
Informs CCB and Storex Control Room (SCR). Also informs Berthing
Master if a vessel is at Berth.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 54

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XXXI. OPERATOR – STOREX

Location:
On Site

Function:
To report any incident and, under the direction of the Shift Supervisor(S)
commence appropriate shutdowns and isolations. Actively participate in
the search/rescue of casualties and initial fire and/or gas control until
arrival of the HSED/ Fire Service to assume responsibility for these
functions.

Reports to:
Shift Supervisor(S).

Initial Response:
Proceeds as instructed, to site of incident rendering assistance as required.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 55

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XXXII. DUTY OPERATIONS SAFETY ENGINEER

Location:
ESCR
Functions:
Assist the FRTL as require, liaise and pass information to SO in ICC
Reports to:
FRTL/SO (ICC).
Initial Response:
On receipt of group alert proceeds to ESCR and liaise with both
emergency services and SO (ICC)

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 56

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XXXIII. SHIFT SUPERVISOR (STOREX)

Location:
Storex Control Room.

Function:
To sound Storex general alarm on instruction of SS.
To direct, on the instructions of the SS or HOP or HOU, personnel to deal
with the emergency.

Reports to:
HOS, HSO or HOP or HOU whoever is in CCB.

Initial Response:


In Storex Control Room.
Commences appropriate measures to bring the emergency under
control by directing Operators either by radio or moving to the
incident site.



On site.
On receipt of an alarm, moves to the incident site to direct Operators.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 57

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XXXIV. TURNAROUND TEAM LEADER

Location:
Central Control Building.
Function:
Provide support to HOP/HOU as required.
Reports to:
HOP/HOU
Initial Response:
On receipt of a Group Alert Signal, if the Marshalling Point has been
designated as either 1, 2 or 3 proceeds along the A1 direct to the CCB.
If Marshalling Point 4, 5, 6, 7 or 8 has been designated, proceeds to the
Marshalling Point indicated along the B1/ First Street and awaits
directions/ instructions from the Operations Controller

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 58

HEALTH, SAFETY, ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No.0
Date: 15.05.08

XXXV. STEAM SHIFT SUPERVISOR (SSS)

Location:
CCB

Function:
To carry out notifications as laid down in section 9.0 specific emergency
actions. To carryout the HOS, HOP/HOU requests as related to control of
trains 1, 2 and 3 utilities areas.
Report to:
HSO, HOP/HOU, whoever is in CCB
Initial Response
On receipt of an alarm carried out function as specified in sec 9.0 (specific
emergency actions)

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM-1

Page No

: 59

HEALTH, SAFETY& ENVIRONMENT DEPARTMENT
ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

8. LOCATION EMERGENCY INSTRUCTIONS
8.1

SUPERVISOR'S RESPONSIBILITIES
It is the responsibility of all supervisors to account for the number and location of
personnel working under their control on the ADGAS facilities.
In the event of an emergency the immediate supervisor SHALL ensure that all
personnel under his control are safely evacuated to the appropriate Marshalling point.

8.2

EVACUATION OF LNG PLANT
On the sounding of the Plant General Alarm, personnel, other than those directly
involved in the emergency, e.g. from Production Division, SHALL take the following
actions:

8.3

z

Stop all work.

z

Shutdown all mobile maintenance equipment.

z

Advise and give assistance to remove personnel working in confined spaces.

z

Proceed windward otherwise - across when in the gas cloud to the nearest safe
Marshalling Point using an escape respirator.

z

Await further instructions.

CENTRAL CONTROL BUILDING (CCB)
8.3.1

H2S Alarm
On the sounding of the H2S Alarm in the CCB personnel SHALL take the
following actions:

8.3.2

z

Stay at their place of work within the Control Room. The fresh air intake
of HVAC system will close upon detection of H2S.

z

Await instruction from Duty Shift Superintendent.

Plant General Alarm
On the sounding of the local alarm or Plant General Alarm non-essential
personnel SHALL take the following actions:

Doc. Number

:

Network Loc.

:

z

Leave their place of work.

z

Shut, but do not lock, doors.

z

Proceed to nearest safe Marshalling Point as directed by WARDENS
using escape respirator if required.

z

Await further instructions.

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEPPM-2

Page No

: 60

HEALTH, SAFETY& ENVIRONMENT DEPARTMENT
ADGAS EMERGENCY RESPONSE PROCEDURES

8.4

Rev. No. 0
Date: 15.05.08

EVACUATION OF QUARRY MAINTENANCE BASE (QMB)
8.4.1

Personnel
On the sounding of the Quarry Maintenance Base Klaxon or the Plant General
Alarm, personnel SHALL take the following actions:

8.4.2

z

Leave their place of work or office.

z

Shut, but do not lock, doors.

z

Assemble in the general working area with escape respirator and await
instructions from the WARDENS.

z

Proceed to the nearest safe Marshalling Point as directed by
WARDENS, using escape respirator.

z

Await further instructions.

Supervisor
z

First available Supervisor SHALL assume the responsibilities of
WARDEN and SHALL carry out the following actions:
„
„
„
„
„

Don fluorescent waistcoat *
Pick up loud hailer *
Pick up radio *
Direct other available Supervisors to assist
Contact CCB for guidance
* Available on mezzanine floor walkway.

z

All other available Supervisors SHALL assist the WARDEN to ensure
the following actions are carried out:
„
„
„
„

8.5

Building is totally evacuated
Machinery is isolated
Crowd is controlled
Any other assistance as requested by the WARDENS

EVACUATION OF STOREX
z

Stop all work.

z

Shutdown all mobile maintenance equipment.

z

Persons on tank tops SHALL return to ground via the stair tower and SHALL
not use the lifts.

z

Proceed across wind, using escape respirator if required, to the nearest safe
Marshalling Point.

z

Await further instructions.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEPPM-2

Page No

: 61

HEALTH, SAFETY& ENVIRONMENT DEPARTMENT
ADGAS EMERGENCY RESPONSE PROCEDURES

8.6

Rev. No. 0
Date: 15.05.08

STOREX CONTROL ROOM
8.6.1 H2S Alarm
On the sounding of the Hydrogen Sulphide Alarm personnel SHALL take the
following actions:
z

Stay at their place of work within SCR. (The fresh air intake of the
HVAC system will close upon detection of H2S.)

z

Await instructions from HSO/HOS.

8.6.2 Evacuation
On the sounding of the Local Fire or CO2 pre-release alarm, personnel SHALL
take the following actions:

8.7

z

Leave their place of work.

z

Shut, but do not lock, doors.

z

Proceed to the nearest safe Marshalling Point using escape respirator if
required.

z

Await further instructions.

EVACUATION OF LNG JETTY
On the instruction of the Jetty Operator, non-essential personnel SHALL take the
following actions:

8.8

z

Stop all work.

z

Shutdown all mobile maintenance equipment.

z

Proceed to Marshalling Point 5 using escape respirator if required.

z

Await further instructions.

EVACUATION OF SULPHUR JETTY
On the instruction of the Jetty Operator, non-essential personnel SHALL take the
following actions:
z

Stop all work.

z

Shut down all mobile maintenance equipment.

z

Proceed to Marshalling Point 8 at Sulphur Storage Facility using escape
respirator if required.

z

Await further instructions.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEPPM-2

Page No

: 62

HEALTH, SAFETY& ENVIRONMENT DEPARTMENT
ADGAS EMERGENCY RESPONSE PROCEDURES

8.9

Rev. No. 0
Date: 15.05.08

EVACUATION OF LABORATORY
On the sounding of the local Fire Alarm, personnel SHALL take the following actions:
z

Leave their place of work or office.

z

Shut, but do not lock, doors.

z

If safe to do so, attack fire with available fire extinguisher.

z

Evacuate the building.

z

Telephone Fire Service, 63333 from safe area.

z

Assemble in the Car Park south of the building.

z

Await further instructions.

Designated WARDENS: As posted in the building
8.10 EVACUATION OF PROJECTS BUILDING
On the sounding of the local Fire Alarm, personnel SHALL take the following actions:
z

Leave their place of work or office.

z

Shut, but do not lock, doors.

z

If safe to do so, attack fire with available fire equipment.

z

Telephone Fire Service, 63333 from safe area.

z

Evacuate the building.

z

Assemble in area Car Park between Projects and OMA Annexe buildings.

z

Await further instructions.

Designated WARDENS: As posted in the building
8.11 EVACUATION OF AL JIMI ACCOMMODATION
On the sounding of the local Fire Alarm personnel/ resident SHALL take the following
actions:
z

Leave their place of work or room.

z

Shut, but do not lock, doors.

z

If safe to do so, attack fire with available fire extinguisher.

z

Evacuate your area to the nearest Marshalling Point.

z

Await further instructions.

Designated WARDENS: As posted in the building

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEPPM-2

Page No

: 63

HEALTH, SAFETY& ENVIRONMENT DEPARTMENT
ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

8.12 EVACUATION OF OMA ANNEX
On the sounding of the local Fire Alarm personnel SHALL take the following actions:
z

Leave their place of work or office.

z

Shut, but do not lock, doors.

z

If safe to do so, attack fire with available fire extinguisher.

z

Telephone Fire Service, 63333 from safe area.

z

Evacuate the building.

z

Assemble in clear area north of building.

z

Await further instructions.

Designated WARDENS: As posted in the building.
8.13 EVACUATION OF ADGAS MAIN OFFICE BUILDING (DAS)
On the sounding of the local Fire Alarm, personnel SHALL take the following actions:
z

Leave their place of work or office.

z

Shut, but do not lock, doors.

z

If safe to do so, attack fire with available fire extinguisher.

z

Call Fire Service, 63333 from safe area.

z

Evacuate the building through the nearest fire exit.

z

Assemble at either Marshalling Points (North or South side)

z

Await further instructions.

Designated WARDENS: As posted in each floor
8.14 EVACUATION OF TRAINING CENTRE
On the sounding of the local Fire Alarm, personnel SHALL take the following actions:
z
Leave their place of work or office.
z
Shut, but do not lock, doors.
z
If safe to do so, attack fire with available fire extinguisher.
z

Telephone Fire Service, 63333 from safe area.
Evacuate the building.
Assemble in Car Park immediately south of ADMA-OPCO Municipal
Maintenance office block.

z
z
z

Await further instructions.

Designated WARDENS: As posted in the building

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEPPM-2

Page No

: 64

HEALTH, SAFETY& ENVIRONMENT DEPARTMENT
ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

8.15 EVACUATION OF CENTRAL WORKSHOPS
On the sounding of the local Fire Alarm, personnel SHALL take the following actions:
z
Stop all work and turn off all machinery.
z
Leave their place of work or office.
z

Shut, but do not lock, doors.
If safe to do so, attack fire with available fire extinguisher.
Telephone Fire Service, 63333 from safe area.
Evacuate the area by the shortest route to open air.

z
z
z
z

Assemble in the open area North side away from CWS.
Await further instructions.

z

Designated WARDENS: As posted in the building
8.17 EVACUATION OF MATERIALS STORE
On the sounding of the local Fire Alarm, personnel SHALL take the following actions:
z
Ensure equipment/machines are switched off.
z
Leave their place of work or office.
z
Shut but do not lock doors.
z

z

If safe to do so, attack fire with available fire extinguisher.
Telephone Fire Service, 63333 from safe area.
Evacuate Stores Area.
Assemble on flat area between CWS and Craft Training Centre.

z

Await further instructions.

z
z

Designated WARDENS: As posted in the building

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

HSEPPM-2

Page No

: 65

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

Rev. No. 0
Date: 15.05.08

ADGAS EMERGENCY RESPONSE PROCEDURES

9. SPECIFIC EMERGENCY ACTIONS
9.1

MAJOR LEAK OF HC/ TOXIC GAS – LNG PLANT
9.1.1

Operators (Plant)
Upon discovering the hazard moves across wind to a position of RELATIVE
SAFETY.
Informs CCB by radio, awaits acknowledgement.
Telephone 62222 stating:-

If not received, calls

"Emergency Gas Leak, Emergency Gas Leak".
Location of Leak.
Details of any known casualties.
Dons BA.
Stops all hot work and engines.
Assists in the accounting of personnel.
Rescues personnel if location is known.
In liaison with CCB, commences appropriate isolations and deployment of gas
cloud control equipment.
Assists in the search and rescue of missing personnel.
9.1.2

Train Shift Supervisor
Acknowledges and repeats message.
Informs HSO of wind direction and Marshalling Points that can be used.
HSO SHALL decide the Marshalling Point to be used.
Telephones ESCR on direct line stating:
"Gas Leak, LNG Plant, Gas Leak, LNG Plant.
Report to Marshalling Point No. ......".
Sounds Plant General Alarm if directed by HSO.
Gives general call over radio to all Operators stating:"Gas Leak at . . . . Wear BA, Gas Leak at . . . . Wear BA".
Liaises with HSO to ascertain measures to be taken.

9.1.3

Power Shift Supervisor
Informs: OC (U).
On instruction from HSO activates Group Alert System and/ or Plant siren.
Contacts OSE stating:

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:66

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Location of Leak.
Report to Marshalling Point No. ......
Ensures that fire pumps have cut in and firemain pressure is adequate.
9.1.4

Jetty Operators (LNG and Sulphur)
Stops all work on Jetty.
Informs Berthing Master (if not on Tanker, at Marine Incident Room).
Stops loading ship and unberths if so directed by Shift Supervisor(s)

9.1.5

Head of Shift Operations
Ensures immediate notifications have been made.
Dispatches an ESLO to the designated Marshalling Point to direct the Fire
Service.
Liaises with Operator(s) at site to determine extent and nature of the leak.
Decides on Plant Siren activation.
In consultation with the FRTL declares alert status and location of Forward
Control.
Considers shutdown requirements of LNG Plant, fired heaters and pilot
burners.
Directs Shift Supervisor(s) to stop loading and, if appropriate, unberth ship.
Considers the shutdown of boilers taking due account of wind direction. If
necessary, shutdown Utilities completely.
Considers the shutdown of electrical generation except that to power essential
services.
Directs Umm-Shaif Supervisor to isolate LNG gas supplies if necessary.
Establishes the approach to control the emergency with FRTL and directs the
OSE to deploy his men as appropriate.
NOTE:
In the event of a MINOR LEAK of HC or toxic gas the HSO, at his discretion,
MAY inform the FRTL of the situation and confirm that no attendance by the
Fire Service is required".
If the FRTL is contacted, the OSE SHALL also be contacted.

9.1.6
Doc. Number

:

Network Loc.

:

Operations Safety Engineer
DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:67

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

Rev. No. 0
Date: 15.05.08

ADGAS EMERGENCY RESPONSE PROCEDURES

Proceeds to the designated Marshalling Point and dons BA.

9.1.7

Awaits instructions from HSO and, if requested, assists in firefighting and
search/rescue activities as directed by the FRTL.
Operations Controller (Process/ Utilities)
Proceeds to site and directs operations liaising with HSO.
Implements HSO instructions relating to plant shutdown and emergency
control.

9.1.8

Head of Process
Proceeds to CCB to release HSO.
Ensures all emergency notifications have been completed.
Liaises with HSO providing assistance as required.

9.1.9

Fire & Rescue Team Leader
Proceeds to designated Marshalling Point where he assumes responsibility for
all actions relevant to control the emergency including search and rescue.
Establishes Forward Control in consultation with the HSO.
In consultation with the HSO, establishes the approach to be taken in
controlling the emergency.
Acts within his discretion in all activities to control the emergency and carry
out search/rescue.
Inform the ESCR of Alert Status.

9.2

OUTBREAK OF FIRE – LNG PLANT
9.2.1

Operators (Plant)
Moves to an area of RELATIVE SAFETY.
Informs CCB by radio, awaits acknowledgement.
telephone 62222 stating:

If not received calls

"Emergency – Fire, Emergency - Fire".
Location of fire.
Details of any known casualties.
Assists in the accounting of personnel.
Stops all hot work and engines.
Rescues personnel if location is known.
Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:68

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

In liaison with CCB commences appropriate isolations and deployment of
firefighting and rescue equipment.
Assists in the search for missing personnel.
9.2.2

Process Shift Supervisor (CCB)
Acknowledges and repeats message or accept fire alarm.
Informs HSO and sounds LNG sirens if instructed to do so.
Informs ADMA Central Control Room.
Relays HSO instructions to Utilities Shift Supervisor (CCB).

9.2.3

Utilities Shift Supervisor (CCB) - Power Desk
Informs Operations Controller (Utilities).
On instruction of the HSO activates Group Alert System and gives a voice
message clearly stating:
Location of fire.
Report to Marshalling Point No. ....
Contacts ADMA-OPCO ESCR by telephone and states:
"Fire at LNG Plant, Fire at LNG Plant,
Report to Marshalling Point No. ....."
Ensures that fire pumps have been started and cut in satisfactory and fireman
pressure is adequate.

9.2.4

Head of Shift Operations
Ensures immediate notifications have been made.
Dispatches an ESLO to the nominated Marshalling Point to direct the Fire
Service.
Liaises with Operator(s) at site to determine extent and nature of fire.
Decides on Plant Siren activation.
In consultation with FRTL (Fire & Rescue Team Leader) declares Alert
Status and location of Forward Control.
Considers LNG Plant shutdown requirements.
Establishes the approach to firefighting and rescue operations with FRTL and
directs the OSE to deploy his men, as appropriate.
Late Fire Call:
Where a minor fire or smouldering has been extinguished without the
attendance of the Fire & Rescue Team Das a "Late Fire Call" SHALL be
made. The contact SHOULD be via the direct line and the following message
sent:

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:69

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

"This is not an Emergency. I repeat. This is not an Emergency.
A fire has occurred on the LNG Plant that has been extinguished.
Please report to Marshalling Point ...."
Minor Fires (i.e. Fires which are immediately extinguished)
Head of Shift Operations will instruct Utilities Shift Supervisor (CCB) to
inform ADMA CCR.
ADGAS duty HSE must be informed of any late fire call so that he can inform
ADGAS Personnel Officer (Relations) who will inform Das Police of the
event
9.2.5

Operations Safety Engineer
Proceeds to designated Marshalling Point.
Awaits instruction from HSO and, if requested, assists in firefighting and
rescue activities as directed by the FRTL (Fire & Rescue Team Leader).

9.2.6

Operations Controller (Process/ Utilities)
Proceeds to site and directs the operations in liaison with HSO.
Implements HSO instructions relating to plant shutdown and firefighting
activities.

9.2.7

Head of Process /Head of Utilities
Proceeds to marshalling point and if safe to CCB or as directed by HSO.
Ensures that all emergency notifications have been completed.
Liaises with Forward Control providing assistance as required.

9.2.8

Fire & Rescue Team Leader
Proceeds to designated Marshalling Point where he assumes the responsibility
for all firefighting and search/rescue activities.
Establishes Forward Control in consultation with the HSO.
In consultation with the HSO, establishes the approach to be taken in
controlling the emergency.
Acts within his discretion in all firefighting and search/rescue activities.
Informs the ESCR of Alert Status.

9.3

MAJOR LEAK OF HC – STOREX

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:70

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

Rev. No. 0
Date: 15.05.08

ADGAS EMERGENCY RESPONSE PROCEDURES

9.3.1

Operators
Moves across wind to a position of RELATIVE SAFETY.
Informs the CCB by radio, awaits acknowledgement.
telephones 62222 stating:

If not received,

"Emergency Gas Leak, Emergency Gas Leak".
Location of leak.
Details of any known casualties.
In liaison with SCR, commences appropriate isolations and deployment of gas
cloud control equipment.
Takes action as requested by HSO.
Assists in the accounting of personnel.
Stops all hot work and engines.
Assists in the search for missing personnel.

9.3.2

Senior Operators
Remains in SCR monitoring shutdown and gas detection equipment.

9.3.3

Head of Storex
Ensures appropriate measures are taken to control the emergency.

9.3.4

Operations Controller (Storex)
Sounds the Storex general alarm on instruction of the SS.

9.3.5

Process Shift Supervisor (CCB)
Acknowledges and repeats message.
Gives general call over radio to all Operators stating:
"Gas Leak at Wear BA, Gas Leak at Wear BA"
Informs HSO of the HC leak and wind direction.
Sounds the LNG Plant Alarm Sirens, if so instructed by HSO.
Informs Umm Shaif Control Room
Liaises with HSO to ascertain measures to be taken.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:71

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

9.3.6

Rev. No. 0
Date: 15.05.08

Utilities Shift Supervisor (CCB)
Telephones ESCR on direct line stating:
"Gas Leak, Storex, Gas Leak, Storex
Report to Marshalling Point No. ......",
Informs SCE (Utilities).
On instruction from HSO activates Group Alert System.
Contacts OSE stating:
Location of Leak.
Report to Marshalling Point No. ......
Ensures that fire pumps have cut in and firemain pressure is adequate.

9.3.7

Jetty Operators
Stops all work on Jetties.
Informs Berthing Master (if not on Tanker, at Marine Incident Room).
Stops loading ship and unberths if so directed by HSO.

9.3.8

Head of Shift Operations
Ensures immediate notifications have been made.
Dispatches an ESLO to the designated Marshalling Point to direct the Fire
Service.
Liaise with HSO and the SCR to determine extent and nature of the leak.
Decides on Plant Siren activation.
In consultation with the FRTL declares alert status and location of Forward
Control.
Considers LNG Plant shutdown requirements and the need for fired heaters
and pilot burners to be extinguished.
Directs HSO to stop loading and, if appropriate, unberth ship.
Considers the shutdown of boilers taking due account of wind direction. If
necessary, shuts down Utilities completely.
Considers the shutdown of electrical generation except that to power essential
services.
Establishes the approach to control the emergency with the FRTL and directs
the OSE to deploy his men, as appropriate.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:72

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

9.4

Rev. No. 0
Date: 15.05.08

9.3.9

Operations Safety Engineer
Proceeds to designated Marshalling Point and dons BA.
Awaits instructions from SS and, if requested, assists in controlling
emergency and rescue activities as directed by the FRTL.

9.3.10

Head of Process/Head of Utilities
Ensures all emergency notifications have been completed.
Liaises with HSO providing assistance as required.

9.3.11

Fire & Rescue Team Leader
Proceeds to designated Marshalling Point where he assumes responsibility for
all actions relevant to control the emergency including search and rescue.
Establishes Forward Control in consultation with the HSO.
In consultation with the HSO, establishes the approach to be taken in
controlling the emergency.
Acts within his discretion in all activities to control the emergency and carry
out search/ rescue.
Inform the ESCR of Alert Status.

OUTBREAK OF FIRE – STOREX
9.4.1

Operators (Storex)
Informs CCB by radio, awaits acknowledgement. If not received telephones
62222 stating:
"Emergency – Fire, Emergency - Fire".
Location of fire.
Details of any known casualties.
In liaison with SCR and OC(S) commences appropriate isolations and
deployment of firefighting and rescue equipment.
Assists in the accounting of personnel.
Stops all hot work and engines.
Assists in the search for missing personnel.

9.4.2

Shift Supervisor Storex {SS(S))
Remains in SCR monitoring shutdown, fire detection and deluge systems.
Takes action as requested by Operations Controller (Storex) {OC(S)}.

9.4.3
Doc. Number

:

Network Loc.

:

Operations Controller (Storex) {OC(S)}
DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:73

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Ensures appropriate measures are taken to control the emergency.
On instructions of HSO sounds the Storex siren.
9.4.4

Head of Storex
Monitors condition as required.

9.4.5

Train Shift Supervisor
Acknowledges and repeats message or accepts fire alarm.
Informs Head of Shift Operations (HSO) and sounds LNG sirens if instructed
to do so.
Informs Umm Shaif Control Room.
Relays HSO instructions to Shift Supervisor (S).

9.4.6

Power Shift Supervisor
Telephones ESCR stating:
"Fire at Storex, Fire at Storex”
Report to Marshalling Point No. ....."
Informs: OC ( Utilities)
On the instructions of the HSO activates Group Alert System.
Contacts OSE stating:
Location of fire.
Report to Marshalling Point No. ....
Ensures that fire pumps have cut in and firemain pressure is adequate.

9.4.7

Head of Shift Operations
Ensures immediate notifications have been made.
Dispatches an ESLO to the nominated Marshalling Point to direct the Fire
Service.
Liaises with Operator(s) at site to determine extent and nature of fire.
Decides on STOREX Siren activation.
In consultation with FRTL declares Alert Status and location of Forward
Control.
Establishes the approach to firefighting and rescue operations with FRTL and
directs the OSE to deploy his men as appropriate.
Late Fire Call:

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:74

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Where a minor fire or smouldering has been extinguished without the
attendance of the Das Island Fire Service a "Late Fire Call" SHALL be made.
The contact should be via the direct line and the following message sent:
"This is not an Emergency, I repeat. This is not an Emergency.
A fire has occurred on the Storex that has been extinguished.
Please report to Marshalling Point...."
9.4.8

Operations Safety Engineer
Proceeds to designated Marshalling Point.
Awaits instructions from HSO and, if requested, assists in firefighting and
rescue activities as directed by the FRTL.

9.4.9

Head of Process/Head of Utilities
Ensures that all emergency notifications have been completed.
Liaises with Forward Control providing assistance as required.

9.4.10

Fire & Rescue Team Leader
Proceeds to designated Marshalling Point where he assumes responsibility for
all firefighting and search/rescue activities.
Establishes Forward Control in consultation with the HSO.
In consultation with the HSO, establishes the approach to be taken in
controlling the emergency.
Acts within his discretion in all firefighting and search/rescue activities.
Informs the ESCR of Alert Status.

9.5

MAJOR LEAK OF HC/ TOXIC GAS – LNG JETTY
9.5.1

Jetty Operators
Stops loading pumps through emergency trip.
Activates manual alarm call point.
Radio CCB stating:
"Emergency Gas Leak - LNG Jetty, Emergency Gas Leak - LNG Jetty.
If not acknowledged telephones 62222 and repeats message.
Informs:Berthing Master (if not on Tanker, at Marine Incident Room).
Ship's Master.
Shift Supervisor(S).

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:75

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Dons BA
Prepares to disconnect loading arms.
Un-berths ship, if instructed by HSO.
Ensures that the Hi-Ex foam system has started operating on auto-mode.

9.5.2

Senior Operator
Remains in SCR monitoring shutdown and gas detection equipment.
Takes action as requested by Head of Storex.

9.5.3

Operations Controller Storex {OC(S)}
Ensures appropriate measures are taken to control the emergency.
Sounds the Storex general alarm on instruction of the HSO.

9.5.4

Head of Storex
Monitors conditions as required.

9.5.5

Train Shift Supervisor
Acknowledges and repeats message.
Telephone ESCR stating:
"Emergency Gas Leak - LNG Jetty, Emergency Gas Leak - LNG Jetty.
Report to Marshalling Point No. 5".
Informs HSO.
Liaises with HSO to ascertain measures to be taken.

9.5.6

Power Shift Supervisor
Informs OC(P), OC(U) or SS(S) as appropriate.
Upon instructions from the HSO activates Group Alert System.
Contacts OSE stating:
Gas leak at LNG Jetty.
Report to Marshalling Point 5.
Ensures fire pumps have cut in and firemain pressure is adequate.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:76

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

9.5.7

Rev. No. 0
Date: 15.05.08

Head of Shift Operations
Ensures immediate notifications have been made.
Dispatches an ESLO to Marshalling Point 5 to liaises with the Fire Service.
Liaises with Jetty Operator through the Shift Supervisor (S) to determine
extent and nature of the leak.
Declares Alert Status and decides on STOREX Siren activation.
Establishes the approach to control the emergency with the FRTL and direct
the SOSE to deploy his men as appropriate.

9.5.8

Operation Safety Engineer (OSE)
Proceeds to Marshalling Point 5 and dons BA.
Awaits instructions from the HSO and, if requested, assists in firefighting and
rescue activities as directed by the FRTL

9.5.9

Head of Process/Head of Process
Ensures that all emergency notifications have been completed.
Liaises with HSO and provides assistance as required.

9.5.10

Operations Controller Storex {OC(S))
Liaises with HSO and provides assistance as required.

9.5.11

9.6

Fire & Rescue Team Leader
Proceeds to Marshalling Point No.5 where he assumes responsibility for all
firefighting and search/rescue activities.
Establishes Forward Control in consultation with the HSO.
In consultation with the HSO, establishes the approach to be taken in
controlling the emergency.
Acts within his discretion in all firefighting and search/rescue activities.
Inform ESCR of Alert Status.

OUTBREAK OF FIRE - LNG JETTY
9.6.1

Jetty Operators
Stops loading pumps.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:77

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Activates manual alarm call point.
Radios CCB stating:
"Emergency-Fire on LNG Jetty, Emergency-Fire on LNG Jetty".
If not acknowledged telephones 62222, repeating message.
Informs:
Berthing Master (if not on Tanker, at Marine Incident Room).
Ship's Master.
Operations Controller Storex {OC(S)}.
Prepares to disconnect loading arms.
Unberths ship if instructed by HSO.
Ensures that the Hi-Ex foam system has started operating.
9.6.2

Shift Supervisor Storex {SS(S))
Remains in SCR monitoring shutdown equipment.
Takes action as requested by OC(S).

9.6.3

Operations Controller Storex {OC(S)}
Ensures appropriate measures are taken to control the emergency.
Sound the Storex general alarm on instruction of the HSO.

9.6.4

Train Shift Supervisor
Acknowledges and repeats message.
Telephones ESCR stating:
"Fire on LNG Jetty, Fire on LNG Jetty".
Report to Marshalling Point No. 5".
Informs HSO and relays his initial instructions to the Jetty Operator.

9.6.5

Power Shift Supervisor
Upon instructions of the HSO activates Group Alert system.
Contacts OSE stating:
"Fire at LNG Jetty.
Report to Marshalling Point No. 5."
Ensures fire pumps have cut in and firemain pressure is adequate.

9.6.6
Doc. Number

:

Network Loc.

:

Head of Shift Operations
DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:78

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Ensures immediate notifications have been made.
Liaises with Jetty Operator to determine extent and nature of fire.
Decides on STOREX Siren activation.
In conjunction with FRTL declares Alert Status.
Establishes the approach to control the emergency with the FRTL and directs
the OSE to deploy his men, as appropriate.
Late Fire Call:
Where a minor fire or smouldering has been extinguished without the
attendance of the Das Island Fire Service a "Late Fire Call" SHALL be made.
The contacts SHOULD be via the direct line and the following message sent:
"This is not an Emergency. I repeat. This is not an Emergency.
A fire has occurred on the LNG Jetty that has been extinguished.
Please report to Marshalling Point No.5."
9.6.7

Operations Safety Engineer
Proceeds to Marshalling Point No 5
Awaits instructions from HSO and assists, if requested, in firefighting and
search/rescue activities as directed by the FRTL.

9.6.8

Head of Operations/ Head of Utilities
Ensures that all notifications have been completed.
Liaises with HSO providing assistance as required.

9.6.9

Head of Storex
Liaises with HSO providing assistance as required.

9.6.10

Fire & Rescue Team Leader
Proceeds to Marshalling Point No.5 where he assumes responsibility for all
firefighting and search/rescue activities.
Establishes Forward Control in consultation with the HSO.
In consultation with the HSO, establishes the approach to be taken in
controlling the emergency.
Acts within his discretion in all firefighting and search/rescue activities.
Informs ESCR of Alert Status.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:79

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

9.7

Rev. No. 0
Date: 15.05.08

PERSON FALLING INTO SEA - LNG JETTY
9.7.1

Observer/ Jetty Operator
Throws nearest lifebuoy for aid. Determines if person in the water is capable
of self help.
Observer to inform Jetty Operator who SHALL radio or telephone the CCB
stating:
"Emergency, Emergency Man in water at ........... ".
Jetty operator SHALL radio or telephone SCR and repeat the above message.
Renders further assistance.
Launches liferaft.
On arrival of assistance dons safety harness / lifeline and lifejacket.
Prepares to enter the water from the sea level platform.
CAUTION:
Enter the water only as a last resort or on specific instructions from HSO or
SS(S) only if capable of swimming and using safety harness/ lifeline and life
jacket.

9.7.2

Storex Control Room Operator
On receiving message from the Jetty Operator contacts ADMA-OPCO Marine
on VHF radio channel 16 and then transfers to channel P2. Communicates the
following message.
"Emergency, Emergency Man in water at ........... Request assistance".
Informs SSS.

9.7.3

Storex Shift Supervisor
Liaises with HSO.
Proceeds to the incident scene.
Maintains contact with Das Marine on channel P2 using portable VHF set
(located in Operator's cabin at Jetty).

9.7.4

Train Shift Supervisor
Acknowledges and repeats message.
Telephones ESCR stating:
"Emergency, Emergency. Man in water at ...........".
Informs HSO.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:80

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

9.7.5

Rev. No. 0
Date: 15.05.08

Power Shift Supervisor
Contacts OSE and Head of Storex and informs them of the situation.

9.7.6

Head of Shift Operations
Ensures immediate notifications have been made.
Liaises with Jetty Operator to determine ability of the casualty to self help.
Liaises with Shift Supervisor (S) regarding Das Marine response to the
request for assistance.
Determines on arrival at the incident site, if a man should enter the water to
rescue the casualty. If it is decided to attempt a rescue the rescuer should
enter the water from the sea level platform only if he is capable of swimming
and using adequate safety gear.

9.7.7

Operations Safety Engineer
Proceeds to Jetty.
Renders assistance as required.

9.8

FIRE AT SULPHUR STORAGE/ JETTY
9.8.1

Jetty Operator
Stops loading pumps.
Activates manual alarm call point.
Radios CCB stating:
"Emergency, Fire on Sulphur Jetty (or Storage Area).
Emergency, Fire on Sulphur Jetty (or Storage Area)".
If not acknowledged, telephones 62222, repeating message.
If Ship is on berth, informs:
Berthing Master (if not on Tanker, at Marine Incident Room).
Ship's Master.
Prepares to disconnect loading arms.
Unberths ship if instructed by HSO.
Commences initial firefighting.

9.8.2
Doc. Number

:

Network Loc.

:

Senior Operator
DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:81

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Remains in SCR monitoring shutdown equipment.
Takes action as requested by Shift Supervisor (S).
9.8.3

Storex Shift Supervisor
Ensures appropriate measures are taken to control the emergency.
Sounds the Storex general alarm on instruction of the HSO.

9.8.4

Train Shift Supervisor
Acknowledges and repeats message
Telephones ESCR stating:
"Fire on Sulphur Jetty (or Storage Area), Fire on Sulphur Jetty (or
Storage Area)". Report to Marshalling Point No. 8".
Informs HSO and relays his initial instructions to the Jetty Operator.

9.8.5

Power Shift Supervisor
On instruction of the HSO activates Group Alert system.
Contacts OSE stating:
"Fire at Sulphur Jetty (or Storage Area). Report to Marshalling Point
No. 8."
Ensures fire pumps have cut in and firemain pressure is adequate.

9.8.6

Head of Shift Operations
Ensures immediate notifications have been made.
Liaises with Jetty Operator to determine extent and nature of fire.
Decides on STOREX Siren activation.
In conjunction with FRTL declares Alert Status.
Establishes the approach to control the emergency with the FRTL and directs
the OSE to deploy his men as appropriate.
Late Fire Call:
Where a minor fire or smouldering has been extinguished without the
attendance of the Das Island Fire Service a "Late Fire Call" SHALL be made.
The contacts SHOULD be via the direct line and the following message sent:
"This is not an Emergency. I repeat. This is not an Emergency.
A fire has occurred on the Sulphur Jetty/ Sulphur Storage that has been
extinguished. Please report to Marshalling Point No. 8."

9.8.7
Doc. Number

:

Network Loc.

:

Operations Safety Engineer
DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:82

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Proceeds to Marshalling Point 8
Awaits instructions from HSO and assists, if requested, in firefighting and
search/rescue activities as directed by the FRTL.
9.8.8

Head of Process/ Head of Utilities
Ensures that all notifications have been completed.
Liaises with HSO providing assistance as required.

9.8.9

Head of Storex
Liaises with HSO providing assistance as required.

9.8.10

Fire & Rescue Team Leader
Proceeds to Marshalling Point No.8 where he assumes responsibility for all
firefighting and search/rescue activities.
Establishes Forward Control in consultation with the HSO.
In consultation with the HSO, establishes the approach to be taken in
controlling the emergency.
Acts within his discretion in all firefighting and search/rescue activities.
Informs ESCR of Alert Status.

9.9

PERSON FALLING INTO SEA - SULPHUR JETTY
9.9.1

Observer/ Jetty Operator
Throws nearest lifebuoy for aid. Determine if person in the water is capable
of self help.
Observer to inform Jetty Operator who SHALL radio or telephone the CCB
stating:
"Emergency, Emergency Man in water at ........... ".
Jetty operator SHALL radio or telephone SCR and repeat the above message.
Renders further assistance.
Launches liferaft.
On arrival of assistance, dons safety harness / lifeline and lifejacket.
Prepares to enter the water from the sea level platform.
CAUTION:

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:83

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Enter the water only as a last resort or on specific instructions from HSO or
Shift Supervisors(S) only if capable of swimming and using safety harness/
lifeline and life jacket.
9.8.2

Storex Shift Supervisor
On receiving message from the Jetty Operator, contacts ADMA-OPCO
Marine on VHF radio channel 16 and then transfers to channel P2.
Communicates the following message:
"Emergency, Emergency Man in water at .... Request assistance".
Informs OC(S).

9.9.3

Storex Shift Supervisor
Liaises with HSO.
Proceeds to incident scene.
Maintains contact with Das Marine on channel P2 using portable VHF set
(located in Operator's cabin at Jetty).

9.9.4

Train Shift Supervisor
Acknowledges and repeats message.
Telephones ESCR stating:
"Emergency, Emergency. Man in water at ...........".
Informs HSO.

9.9.5

Power Shift Supervisor
Contacts OSE and OCS(S) and informs them of the situation.

9.9.6

Head of Shift Operations (HSO)
Ensures immediate notification have been made.
Liaises with Jetty Operator to determine ability of the casualty to self help.
Liaises with Head of Storex (HOS) regarding Das Marine response to the
request for assistance.
Determines on arrival at the incident site, if a man should enter the water to
rescue the casualty. If it is decided to attempt a rescue the rescuer should
enter the water from the sea level platform with adequate safety gear and
SHALL be capable of swimming.

9.9.7
Doc. Number

:

Network Loc.

:

Operations Safety Engineer
DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:84

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Proceeds to Jetty.
Renders assistance as required.

9.10 MAJOR INJURY OR ILLNESS
9.10.1

Site Personnel
Contacts Head of Shift Operations (HSO) or if in Storex area, Head of
Storex (HOS) by radio or calling telephone 62222.
State the following:
Emergency accident, Emergency accident
Location of accident.
Number of persons injured.
Nature of injuries, if known.
CAUTION:
Casualties SHALL not be moved unless leaving them will increase the risk of
further injury.
Casualties SHOULD be given first aid treatment until medical arrives on site.

9.10.2

Process Shift Supervisor (CCB)
Acknowledges and repeats message.
Informs HSO.

9.10.3

Power Shift Supervisor (CCB)
Telephones ESCR stating:
Emergency-accident, Emergency-accident at ……..
Number of persons injured.
Nature of injuries, if known.
Request Ambulance.
Request assistance, if required, for rescue purposes.
Marshalling Point to be used.
Informs OC(P) or OC(U) - depending on accident location.
Contacts OSE stating location of injured personnel and Marshalling Points to
be used.

9.10.4

Doc. Number

:

Network Loc.

:

Head of Shift Operations

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:85

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Despatches an ESLO to the designated Marshalling Point to direct Ambulance
and, if required, Fire Service to scene of accident.
Ensures that the appropriate notifications have been made.
Informs OM and MHSE.
9.10.5

Operations Safety Engineer
Proceeds to the designated Marshalling Point.
As instructed by HSO proceeds to accident location and assists in the
organisation of rescue and first aid activities.

9.11 LOSS OF RADIOACTIVE SOURCE
9.11.1

Introduction
Radioactive sources are used primarily by two Sections within ADGAS, the
Instrument Section of Maintenance Dept and C&ID. In the event of any
suspected loss of, or damage to, any sealed source of radioactive material, the
following procedure shall be followed or as advised by the RPS.

9.11.2

Instrument Engineer/ Plant Inspection Engineer
Informs CCB by telephone 62222.
Ensures that all personnel leave the immediate vicinity of the source.
Erect barriers carrying warning notices defining the hazardous area.
Assist the RPS in reduction of radiation levels and retrieval of source.

9.11.3

Process Shift Supervisor (CCB)
Informs HSO.
Informs RPS stating location of emergency and the reporting point.

9.11.4

Power Shift Supervisor
Contacts OSE stating nature and location of emergency.

9.11.5

Head of Shift Operations
Ensures immediate notification have been made by Shift Supervisor Utilities
SS(U) and Shift Supervisor (P).
Ensures all personnel have evacuated the area by liaising with OC(P) or
OC(U).

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:86

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Ensures barriers are erected around the area at a maximum reasonable
distance from the scene to keep the radiation levels within limits at the
boundary.
Through OC (P) or OC(U), liaises with the RPS to retrieve the source.
9.11.6

Operations Controller
Upon instructions from HSO proceeds to the area.
Liaises with the Instrument Engineer / Inspection Engineer and the HSO.
Ensures personnel have left the area.
Erects barriers around the area.
Awaits arrival of RPS for further advice/information.

9.11.7

Radiological Protection Supervisor
Ensures all personnel have left the immediate vicinity of the source.
Ensures all barriers are set at correct distance.
Takes such steps as are necessary to reduce exposure and retrieve the source.

9.11.8

Operations Safety Engineer
Proceeds to the site.
Assists the RPS as required.

9.12 QUARRY MAINTENANCE BASE EMERGENCY
9.12.1

Wardens
Upon hearing the local H2S alarm, telephones 62222 and seeks advise for
safest evacuation route and Marshalling Point.
Instruct personnel to wear escape respirators.
On arrival at the safe Marshalling Point, carries out a head count and informs
CCB of any missing persons.
Contacts HOM.
Awaits further instructions.

9.12.2

Train Shift Supervisor
Acknowledges and repeats message.
If gas alarm, gives general call over radio to all Operators stating Gas Alarm
QMB, Gas Alarm QMB.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:87

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Informs HSO.
Informs Umm-Shaif Control Room.
Requests Plant 26 Operator to close Road A1.
9.12.3

Power Shift Supervisor
If it is a MAJOR LEAK, telephones ESCR stating:
"Gas Alarm Quarry Maintenance Base, Gas Alarm Quarry Maintenance
Base Report to Marshalling Point No. ....."
If instructed by HSO activates the Group Alert system.
Informs OC(P) or OC(U) as appropriate.
Contacts OSE stating:
Gas Alarm Quarry Maintenance Base. Report to Marshalling Point No.."

9.12.4

Head of Shift Operations
Ensures immediate notifications have been made.
Despatch an ESLO to the nominated Marshalling Point to direct the Fire
Service.
Liaises with Wardens and Operators to determine concentration/extent and
source of gas.
Declares Alert Status.
Dependent on wind direction and source of leak proceeds as for MAJOR
LEAK

9.12.5

Operations Safety Engineer
Proceeds to Marshalling Point and dons BA.
Ensures that HSED personnel dons BA.
Awaits instructions from the HSO and assists in gas dispersion and search/
rescue activities as directed.

9.12.6

Head of Process/ Head of Utilities
Ensures that all emergency notifications have been completed.
Assists HSO as required.

9.12.7

Fire & Rescue Team Leader
Proceeds to designated Marshalling Point where he assumes responsibility for
all measures required to bring the situation under control.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:88

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Establishes Forward Control in consultation with HSO.
In consultation with the HSO, establishes the approach to be taken in
controlling the emergency.
Informs ESCR of Alert Status.

9.13 DAS ISLAND POWER STATION - EMERGENCY RESPONSE
9.13.1

Outbreak of Fire
Alert the Fire Services immediately by emergency telephone No.63333 or
radio to the CCB and activate the break glass alarm (where applicable).
Say,

"Emergency - Fire at Power Station",
"Emergency - Fire at Power Station".

Give precise details stating:Location of fire, e.g. inside turbine canopy, turbine hall, secondary
scrubbers, main gas skid, switch rooms, offices, control rooms, etc.
Type of fire, e.g. pump gland, flange leak, electric, etc.
Details of any known injuries.
In case of small fire attempt to extinguish using the available fire
extinguisher.
In the event of a major fire:Restrict access of personnel and vehicles.
Informs HSO/HOU/OC(U) by radio.
CAUTION:
Under no circumstances SHALL a person take undue risks in attempting to
extinguish a fire.
The following specific actions SHALL be taken by Operations staff for fire in
the areas listed below:
i

Fire Inside Turbine Canopy
GT shuts down and release CO2 automatically, if not use manual
procedure.
Shut off gas and fuel oil supplies to GT.
Vent gas line to atmosphere and drain fuel oil line.
Leave all doors closed and standby for Emergency Services.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:89

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

ii

Rev. No. 0
Date: 15.05.08

Fire in Turbine Hall
Evacuate all personnel from area concerned.
Shutdown GT(s). If applicable, isolate source of combustion and
vent/drain fuel lines.
Switch off turbine hall supply fans.
Fire in electrical equipment to be isolated if possible.
Close all doors and standby for Emergency Services.

iii

Fire at Secondary Scrubbers
In the event of a gas fire on scrubbers, change all GTs to fuel oil, close
main gas valve and open the main gas vent.
Standby for Emergency Services.

iv

Fire at Main Gas skid
Change GTs to fuel oil and isolate main gas valve.
If the fire makes isolation impossible contacts ADMA production to
isolate and vent at the Production Plant.
Standby for Emergency Services.

v

Fire at Switch Rooms
Evacuate all personnel from area concerned.
Auto fire protection SHALL operate. If not then operate on manual.
Leave all doors closed and standby for Emergency Services.

vi

Fire at Office and Control Room
Evacuate all personnel from area concerned.
Leave all doors closed and standby for Emergency Services.

9.13.2

Gas or Oil Leak
Don BA.
Move across wind to a safe location.
At the earliest opportunity alert persons in the immediate vicinity and raise the
alarm.
Informs HSO/OC(U) by radio saying

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:90

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

"Emergency - Gas Leak at Power Station", "Emergency - Gas Leak at
Power Station".
Exact location.
Wind direction if possible.
Remain in safe location and restrict the entry of persons. Vehicles shall be
stopped and their engines switched off.
Any 'Hot work' shall be stopped and any non-flameproof type electrical
equipment shall be left untouched, i.e. do not switch off or on.
The following specific actions SHALL be taken by Operations staff for gas
leak in the area listed below:
i

Gas Leak Inside Turbine Canopy
GT shuts down automatically, if not use manual procedure.
Shut off gas supply.
Vent gas line.
Leave all doors closed and standby for Emergency Services.

ii

Gas Leak Inside Turbine Hall
Evacuate all personnel from area concerned.
Change to fuel oil, isolate gas to turbine hall and vent lines.
Standby for Emergency Services.

iii

Gas Leak at Secondary Scrubbers
Change GTs to fuel oil, close main gas valve and vent lines.
Standby for Emergency Services.

iv

Gas Leak at Main Gas Skid
Change GTs to fuel oil isolate main gas valve, isolate GT scrubbers and
vent down line.
Standby for Emergency Services.

9.14 SEA WATER LAYDOWN AREA (TEMPORARY WASTE STORAGE SITE)
Normally waste are kept till they are ready for shipment to Ruwais / Waste Disposal
Area.
In case of fire: -

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:91

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

9.14.1

Rev. No. 0
Date: 15.05.08

Utilities Operator
Inform CCB by radio or telephone 62222 by stating “Fire, Fire at old SWI
Area. Give details of any casualty damage etc.
Commences deployment of fire fighting and rescue equipment.
Stop all work and evacuate personnel to Marshalling points 2 or 3 as
appropriate.

9.14.2

Utilities Senior Operator
Ensure appropriate measures are taken to control the emergency.

9.14.3

Operations Controller
Contact duty OSE stating the location of fire and takes over as incident
controller.

9.11.6

Head of Shift Operations
Ensure immediate notification has been made.
Dispatch Emergency Service Liaison Operator to Marshalling Point.
Liaise with Operations Controller at site to determine extent and nature of
fire.

Where a minor fire smouldering has been extinguished without the attendance area of
Das Island Fire Service, a late fire call should nevertheless be made. The contact
should be via the direct line.
9.15. MAJOR LEAK OF LIQUID SULPHUR – LNG PLANT – PLANT 7
9.15.1

Operators (Plant)
Move to an area of relative safety.
Inform CCB by radio, await acknowledgement. If not received, phone Tel.
62222 stating:
“Emergency – Sulphur leak, Emergency – Sulphur leak.”
Location of the sulphur leak and extent of leak.
Details of any known causalities.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:92

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Stops all hot work and engines. Assist in the accounting of personnel.
Stops all other work and ensures non-essential personnel evacuate to selected
Marshalling Point.
Dons protective clothing and rescues personnel if location is known and can
be accomplished without undue risk.
In liaison with CCB commence appropriate isolations and deployment of fire
fighting and rescue equipment.
Assist in the search for missing personnel.
9.15.2

Process Shift Supervisor (CCB)
Acknowledges and repeats message.
Inform HSO.
Inform ADMA CCR
Relays HSO instruction to Process Shift Supervisor.

9.15.3

Power Shift Supervisor (CCB)
Activates the group alert if advised by HSO.
If group alert activated establishes contact to ESCR by telephone etc. Must
allow time for ESCR team to assemble.
Telephone ESCR stating:
“Sulphur leak at LNG plant”.
Report to Marshalling point No._____________
Ensures that fire pumps have cut in and firemain pressure is adequate.

9.15.4

Head of Shift Operations
Advises Process Shift Supervisor on group alert status.
Ensures immediate notifications have been made.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:93

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Decides and communicates the Marshalling Point.
Dispatches an ESLO to the nominated Marshalling Point to direct the Fire &
Rescue Services and advises status to all group alert members arriving at
Marshalling Point.
Liaises with Operator(s) at site to determine extent and nature of the liquid
sulphur leak.
In consultation with FRTL declares Alert Status and location of Forward
Control.
Considers LNG Plant (Sulphur Plant) shutdown requirements.
Following arrival of HP in CCB proceeds to incident scene to establish the
approach to fire fighting / containment and rescue operations with FRTL and
directs the OSE to deploy his men, as appropriate, and consults with Area
Operations Incident Controller (Operations Controller).
Late “Fire” Call.
Where a minor leak has been stopped and the attendance of the Das Island
Fire & Rescue Services is not required a “Late Fire Call” shall be made. The
contact should be via the direct line and the following message sent.
“This is not an emergency. I repeat this is not an emergency. A minor
sulphur leak occurred on the LNG Plant. The leak has been stopped.
Please report to Marshalling Point _____________
9.15.5

Operations Safety Engineer
Proceeds to designated Marshalling Point.
Awaits instruction from HSO and, if requested, assists in fire fighting,
containment and rescue activities as directed by FRTL

9.15.6

Operations Controller (Process)
Proceeds to incident location and directs the Operations in liaison with HSO.
Assumes responsibilities of Incident Controller.
Implements HSO instructions relating to Plant shutdown, fire fighting and
containment activities.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:94

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Confirms head count and initiate initial search and rescue activities.
Isolation and deployment of emergency equipment.
9.15.7

Head of Process/ Head of Utilities
Proceeds to nominated Marshalling Point and if safe, to CCB, as directed by
HSO.
Consults with HSO and status of emergency.
Co-ordinates deployment of plant emergency actions.
Ensures that all emergency notifications have been completed.
Liaises with Forward Control. Providing assistance as required.
Advises OM on any developments and status of emergency.

9.15.8

Fire & Rescue Team Leader
Proceeds to designated Marshalling Point where he assumes the responsibility
for all fire fighting, containment and search/rescue activities.
Establishes Forward Control in consultation with the HSO.
In consultation with the HSO, establishes the approach to be taken in
controlling the emergency.
Acts within his discretion in all fire fighting, containment and search/rescue
activities.
Informs ESCR of Alert Status.

9.16 MAJOR LEAK OF LIQUID SULPHUR – RUNDOWN LINE
9.16.1

Operators
Move to an area of relative safety.
Inform CCB by radio, awaits acknowledgement.
When acknowledgement received state:-

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:95

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

“Emergency – sulphur leak on rundown line.”
“Emergency – sulphur leak on rundown line.”
State exact location of the sulphur leak.
Give details of any known casualties.
Stop all pedestrian / vehicle movement as well as all work and engines in the
vicinity of the sulphur leak.
If necessary close the road at a suitable distance from the leak by stopping any
passing vehicle.
Contact ADGAS Storex Control Room and request shift vehicle to come to
leak location and close off access at a safe distance from the leak.
Ensure Fire & Rescue Services will have access if required.
9.16.2

Storex Shift Supervisor
Contacts CCB and liaises with HSO to minimise the leak.
Proceeds to the area of the sulphur leak in the Storex shift vehicle and closes
off the road if necessary.
Informs Sulphur Ship Master if a ship is alongside Berth No. 5.

9.16.3

Head of Storex
Proceeds to nominated Marshalling Point then onto the ADGAS Storex
Control Building by the safest route.
Liaises with HSO and OC(S) in the field to contain liquid sulphur spillage and
shutdown/isolate plant as required.
Ensures correct Safety Equipment / PPE is utilised when evaluating the leak.

9.16.4

Train Shift Supervisor
Acknowledges and repeats message.
Informs HSO.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:96

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Informs ADMA CCB by fax (e-mail) and telephone “Sulphur leak on
rundown line”. Location _________________
Confirms the affected Das Island road has been closed to traffic.
Relays HSO instructions to Shift Supervisor(S).
9.16.5

Power Shift Supervisor
When confirmed that ESCR is manned.
Telephones ESCR stating:“Leak on Sulphur rundown line, leak on sulphur rundown line.”
Location
Ensures that fire pumps have cut in and fire main pressure is adequate.

9.16.6

Head of Shift Operations
Ensures immediate notifications have been made especially to ADMA-OPCO.
Informs ADMA-OPCO Process Superintendent that there is a serious molten
sulphur leak on the rundown line to storage.
Gives exact location of the leak.
Liaises with the Shift Supervisor(S) and Operator(s) at the leak location to
determine severity of the leak and hazards it is creating.
In consultation with FRTL declares Alert Status and location of Forward
Control ( following arrival of HO in CCB ).
Considers LNG Plant / Sulphur Plant shutdown requirements.
Establishes the approach to containment, fire fighting and rescue operation
with FRTL and directs SOSE to deploy his men, as appropriate.
Late Fire Call
Where a minor liquid sulphur leak from the rundown line has stopped without
the attendance of F&RS(D) a “Late Call” shall be made. The contact should
be via the direct line and the following message sent.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:97

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

This is not an emergency. I repeat, this is not an emergency.
A liquid sulphur leak occurred on the sulphur rundown line at
(Location). The leak has now stopped.
Please report to Marshalling Point
9.16.7

.

Operations Safety Engineer
Proceeds to designated Marshalling Point.
Awaits instructions from HSO and, if requested, assists in containment, fire
fighting and rescue activities as directed by FRTL.

9.16.8

Storex Shift Supervisor
Proceeds in the shift vehicle to the vicinity of the leak and closes the road to
prevent access to the area.
Liaises with HSO to direct Operations.
Implements HSO instructions relating to containment, plant shutdown and fire
fighting activities.

9.16.9

Head of Process
Proceeds to Marshalling Point and if safe to CCB, or as directed by HSO.
Ensures all emergency notifications have been completed, especially to
ADMA OPCO.
Contacts ADMA OPCO Head of Das Process and gives details of the liquid
sulphur leak.
Coordinates maintenance support from HOM and Lead Engineers.
Advises OM of status and updates regularly.

9.16.10 Fire & Rescue Team Leader
Proceeds to the designated Marshalling Point where he assumes the
responsibility for all containment, fire fighting and rescue activities.
Establishes a forward control in consultation with HSO.
Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:98

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

In consultation with the HSO, establishes the approach to be taken in
controlling the emergency.
Acts within his discretion in all containment, fire fighting and rescue
activities.
Informs ESCR of Alert Status.

9.17 MAJOR LEAK OF LIQUID SULPHUR – SULPHUR STORAGE/JETTY
9.17.1

Jetty Operator
Stops loading pumps.
Activates manual alarm call point.
Radios CCB stating:“Emergency, Liquid Sulphur Leak on Sulphur Jetty” (or Storage Area).
“Emergency, Liquid Sulphur Leaks on Sulphur Jetty” (or Storage Area).
If not acknowledged, telephones 62222 repeating the above message.
If a ship is on the berth, informs the Berthing Master and Ship’s Master (by
Marine Radio which is on the International channel).
Prepares to disconnect loading arms.
Unberths ship if instructed by HSO.
Attempts to isolate the leaking line.

9.17.2

Senior Operator (Storex)
Remains in Storex Control Room (SCR) monitoring shutdown of equipment.
Takes action as requested by Shift Supervisor(Storex).

9.17.3

Shift Supervisor(S)
Ensures appropriate measures are taken to contain the leaking molten sulphur.
Sounds Storex General Alarm on instruction of HSO.

9.17.4

Doc. Number

:

Network Loc.

:

Process Shift Supervisor (CCB)

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:99

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Acknowledges message from Jetty Operator (Storage Area Operator) and
repeats message.
Following initiation of the Group Alert and allowing time for the ESCR team
to assemble.
Telephones ESCR stating:“Major Sulphur Leak on the Sulphur Jetty” (in the Sulphur Storage Area).
Informs HSO that ESCR is activated and are aware of the situation.
9.17.5

Power Shift Supervisor
On instructions of the HSO activates group alert system.
Contacts OSE stating:
“Major Sulphur Leak on Sulphur Jetty” (or Sulphur Storage Area).
Report to Marshalling Point 8.
Ensures fire pumps have cut in and fire main pressure is adequate.

9.17.6

Head of Shift Operations
Ensures immediate notifications have been made.
Liaises with the Jetty Operator (or Storage Area Operator) to determine extent
and severity of the liquid sulphur leak.
In conjunction with FRTL declares Alert Status.
Liaises with FRTL at the incident scene following handover to HOP in CCB.
Establishes the approach to control/contain the leak with the FRTL and directs
OSE to deploy his men as appropriate to assist in the control and containment
of the Liquid Sulphur Leak (at the Sulphur Jetty or in the Sulphur Storage
Area).
Late ‘Fire” call.
Where a liquid sulphur leak has stopped or is considered minor and the Das
F&RS are not required to attend a “Late Fire Call” shall be made.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:100

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

The contact should be made using the direct line and the following message
given.
“This is not an Emergency. I repeat, this is not an Emergency”.
A liquid sulphur leak has occurred on the Sulphur Jetty (Sulphur Storage
Area). The leak has stopped / is minor and has been safely contained by
Operations Personnel.
9.17.7

Operations Safety Engineer
Proceeds, as instructed to Marshalling Point 8.
Awaits instructions from HSO to assist if required, in isolation and
containment of the liquid sulphur leak on the Jetty or in the sulphur Storage
Area as directed by FRTL.

9.17.8

Head of Process
Ensures all notifications have been completed listed as:Liaises with HSO providing assistance as required.
Takes control in CCB when HSO proceeds to incident scene.

9.17.9

Head of Storex
Liaises with HSO providing assistance, as required, at the incident scene.
If a ship is on Berth, establishes contact with both Berthing Master and Ship’s
Master for any actions required.

9.17.10 Fire & Rescue Team Leader
Proceeds to Marshalling Point 8 where he assumes responsibility for all spill
containment activities.
Establishes Forward Control in consultation with HSO (Sulphur Jetty or
Sulphur Storage Area).
In consultation with HSO establishes the approach to be taken to isolate and
contain the liquid sulphur spillage.
Acts within his discretion in all liquid sulphur containment activities.

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:101

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

Rev. No. 0
Date: 15.05.08

Informs ESCR of Alert Status.

10. ABBREVIATIONS AND ACRONYMS
ADGAS
Abu Dhabi Gas Liquefaction Company
ADMA-OPCO
Abu Dhabi Marine Operating Company
BA
Breathing Apparatus
C&ID
Corrosion & Inspection Department
CCB
Central Control Building
CH
Charge Hand
CNIA
Critical National Infrastructure Authority
CWS
Central Workshop
DIF&RS
Das Island Fire & Rescue Service
EM
Engineering Manager
ERPM
Emergency Response Procedures Manual
ESCR
Emergency Services Control Room
ESLO
Emergency Services Liaison Operator
FRTL
Fire & Rescue Team Leader
H2S
Hydrogen Sulphide
HC
Hydro Carbon
HOM (P)
Head of Maintenance (Process)
HOM (U)
Head of Maintenance (Utilities)
HOM (S)
Head of Maintenance (Storex)
HOP
Head of Process
HOS
Head of Storex
HOU
Head of Utilities
HSED
Health, Safety and Environment Department
HSEMS
Health, Safety & Environment Management System
HSO
Head of Shift Operations
HVAC
Heating, Ventilation and Air Conditioning
ICC
Incident Commander Centre
LEE(M) (U) Lead Electrical Engineer Maintenance (Utility)
LIE(M) (P) Lead Instrument Engineer Maintenance (Process)
LME(M) (P) Lead Mechanical Engineer Maintenance (Process)
LNG
Liquefied Natural Gas
MDA
Manager Das Asset
MDO
Manager Das Operations
MHSE
Manager Health, Safety and Environment
MDM
Maintenance Manager
MOGTS
Manager of General Tech. Services
OC(P)
Operations Controller (Process)
OC(U)
Operations Controller (Utilities)
Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:102

HEALTH, SAFETY & ENVIRONMENT DEPARTMENT

ADGAS EMERGENCY RESPONSE PROCEDURES

OC(S)
OM
OSE
PSS
QMB
RPS
SCR
SE(P)
SE (T)
SEE
SIE
SK
SME
SOSE
SS(P)
SS(S)
SS(U)
SSE(D)
SSE(P)
SSK
ST

Rev. No. 0
Date: 15.05.08

Operations Controller (Storex)
Operations Manager
Operations Safety Engineer
Power Shift Supervisor
Quarry Maintenance Base
Radiological Protection Supervisor
Storex Control Room
Safety Engineer(Project)
Safety Engineer (Technical) - ADMA-OPCO
Senior Electrical Engineer
Senior Instrument Engineer
Store Keeper
Senior Mechanical Engineer
Senior Operations Safety Engineer
Shift Supervisor(Process)
Shift Supervisor (Storex)
Shift Supervisor(Utilities)
Senior Safety Engineer (Das) ADMA-OPCO
Senior Site Safety Engineer(Project)
Senior Store Keeper
Safety Technician

Doc. Number

:

Network Loc.

:

DAS/12/25

Prepared By
Directory Name

:

HSED

Approved By

: PM

ERPM

Page No

:103

Table 1a Emergency Manning Matrix
LOCATION

POSITION

NAME
M.S. Al Shehhi

INCIDENT COMMAND CENTRE

Incident
commander

Safety Officer
Liaison
Information
Officer

Operation Section
Chief

Planning Section
Chief

Technical
Specialist Unit
Leader

Supply Unit
Leader
Communication
unit Leader
Finance Admin
Section Chief

ADGAS CCB

HR Unit Leader

Source Control
Coordinator

Maintenance
Support

Operation
Support

ADGAS SITE

Source Control
Team Leader

Site Safety Officer

Perimeter Control
Supervisor

TITLE
PM

PAGER

OFF. TEL.

RES. TEL.

MOBILE

610

69222

8731188

4438881

V. Grech

APM

610

69111

8731302

Nil.

Khalid Osman

OM

610

69100

69092

5365825

Khalid Al Amri

OM

610

69395

8731287

Nil

Alawi Saleh

MDM

610

69010

8731949

6412378

Ahmed Abbas

I&QM

610

69555

8731176

6550780

A.M. Al-Zaabi

EM

610

69090

8731069

6679616

Rashid Al Merri

SOSE

277

69006

8731140

6217826

Samer Majid

SOSE

277

69115

6710804

Nil.

Mohamed Rezkallah

SSSE(P)

277

62453

8731023

Nil.

Najeh Al Sayed Ibrahim

SSSE(P)

277

69114

62572

Nil.

Ahmed Moh'd Ahmed

PO( R )

161

62444

Nil.

8137846

Jalal Al Marzouqi

PO( R )

161

62160

Nil.

8189168

Khalid Osman

OM

620

69100

69092

5365825

Essam Soudah

HOP

620

69100

69535

504450238

Ezzat El Thany

HOP

620

69395

8731720

5213937

Saeed Al Marzouqi

HOU

620

69395

8731844

4555626

Bassam El Kubba

AC (P)

620

62685

Nil.

6140377

Hassan Moh'd Hassan

AC (P)

620

62691

Nil.

Nil

Mohsen Shehata

AC (P)

620

62691

Nil.

Nil

Alawi Saleh

MDM

630

69010

8731949

6412378

Sherif Hegazi

HOM (P)

630

69010

8731247

Nil

Mohammad Natsir

HOM(U)

630

62365

Nil

4117145

C.M. Akram

HOM(U)

630

62365

69335

Dawood Al Mardoud

HOM(P)

630

62858

8731178

6142638

Nashaat M. Mohamed

PETL

613

62678

873115

5128570

Anjan K. Das

SPE

613

62066

Nil

Nil

Abdul Kader Ibrahim

SE(P)

613

62470

Nil.

4179029

Abdul Razak Al Hammadi

SE(P)

613

62002

Nil.

5375751

Daud Rinding Padang

SE(P)

613

62024

Nil.

7229408
4575599

Mohamed Al-Ali

SE(P)

613

62163

Nil.

Muhammad Adnan Syarif

SE(P)

613

62091

Nil.

Nil.

Saeed Salem Al Hosani

SE(P)

613

62029

Nil.

3337758

Ali Abu Taleb

HMO

167

69494

8732875

6682757

Ghaith Al Suwadi

SSS

167

62768

68886

6849000

Abdulla Al Hamed

SSQA

167

62762

Mohamed Salem

Telecom Engg

138

69300

62244

5924809

6170292

Sarfaraz Ul Hasan

Telecom Engg

138

69300

62494

7918385

Nozad Yahya Mohammed

Telecom Tech

138

69300

Nil

5924782

Mohamed Al Tameemi

AMD

124

69333

8732020

4440095

Abdulla Al Saqool

SPO

124

62435

8732322

Nil

Ahmed Mohamed Ahmed

PO( R )

124

62444

Nil

8137846
8189168

Jalal Al Marzouqi

PO( R )

124

62160

Nil

Abdulla Al Saqool

SPO

333

62435

8732322

Nil

Mansoor Al Mansoori

PO

333

62066

8732573

Nil.

Khalid Al Amri

HO

276

69395

8731287

Nil

Ezzat El Thany

DOS

276

69395

8731720

5213937

Essam Soudah

HOS

620

69100

69535

504450238

Saeed Al Marzouqi

DOS

276

69395

8731844

4555626

Bassam El Kubba

AC (P)

276

62685

Nil

6140377

Ibrahim Mohammed

AC(O)

276

62250

Nil

Nil

Hassan Moh'd Hassan

AC (P)

276

62691

Nil

Nil.

Mohsen Shehata

AC (P)

276

62691

Nil

Nil.

Yousif Kassim

AC (P)

276

69291

Nil

7128093

C.M. Akram

HOM(U)

640

62365

8731737

Nil

Mohammad Natsir

HOM(U)

640

62365

Nil

4117145

Sherif Hegazi

HOM(P)

640

62858

32815

Nil

Dawood Al Mardoud

HOM(P)

640

62858

8731178

6142638

Prafull Pandav

SOE

289

62859

8732166

Nil.

M.Vasagam

LOE

289

62613

62536

Nil.

Jasim Al-Hammadi

OE

289

62280

Nil

Nil.

Imad Abdulla

AC(U)

289

62527

8731599

6215875

Ahmed Al Hosani

SS (Des)

296

69440

8732771

4491988

Abubaker Kassem

SS

296

69440

Nil.

5461003

Saeed Al Zaabi

SS

296

69440

8731590

6613579

Nassim Massih

SS
SS

296

69440

D.J. Eid

296

69440

Obaid Rashid Hammed Ali

OSE

286

62114

8731869

Nil

Abdalla Al Hashmi

OSE

286

62114

8731834

Nil

Abdo Al Gaishi

OSE

286

62114

8732836

Nil

Mohd Saeed Al Ameri

OSE

286

62114

8732191

Nil

8731241
8732586

Nil.
6113390

Fayez Al-Akbari / K. M.Al Mehairi

Safety Tech

288

62247

Nil

Nil

Suryan Krishnan./Mazen Al Zaabi

Safety Tech

288

62247

Nil

Nil

Moh'd Sankar / Moh'd Al Mehairi

Safety Tech

288

62247

Nil

Nil

Mohd Al-Zaabi / Mubarak Al-Zaabi

Safety Tech

288

62247

Nil

Nil

Omar Marzooq

Safety Tech

288

62247

Nil

Nil

21

Table 1b Weekly Duty Availability Roster
Period
LOCATION

POSITION

Incident commander

INCIDENT COMMAND CENTRE

Safety Officer
Liaison Information Officer
Operation Section Chief
Planning Section Chief
Technical Specialist Unit Leader
Supply Unit Leader
Communication unit Leader
Finance Admin Section Chief

ADGAS CCB

Source Control Coordinator
Maintenance Support
Operation Support

ADGAS SITE

Source Control Team Leader
Site Safety Officer
Perimeter Control Supervisor

NAME
M.S. Al Shehhi

TITLE
PM

From

To

PAGER OFF. TEL. RES. TEL.
610

69222

8731188

MOBILE
4438881

V. Grech

APM

610

69111

8731302

Nil.

Rashid Al Merri

SOSE

277

69006

8731140

6217826

Samer Majid

SOSE

277

69115

6710804

Nil.

Ahmed Moh'd Ahmed

PO( R )

161

62444

Nil.

8137846

Jalal Al Marzouqi

PO( R )

161

62160

Nil.

8189168

Khalid Osman

OM

620

69100

69092

5365825

Essam Soudah

HOP

620

69100

69535

504450238

Alawi Saleh

MDM

630

69010

8731949

6412378

Sherif Hegazi

HOM (P)

630

69010

8731247

Nil

Nashaat M. Mohamed

PETL

613

62678

873115

5128570

Anjan K. Das

SPE

613

62066

Nil

Nil

Ali Abu Taleb

HMO

167

69494

8732875

6682757

Abdulla Al Hamed

SSQA

167

62762

Mohamed Salem

Telecom Engg

138

69300

62244

5924809

Sarfaraz Ul Hasan

Telecom Engg

138

69300

62494

7918385

6170292

Mohamed Al Tameemi

AMD

124

69333

8732020

4440095

Abdulla Al Saqool

SPO

124

62435

8732322

Nil

Khalid Al Amri

HO

276

69395

8731287

Nil

Ezzat El Thany

DOS

276

69395

8731720

5213937

Sherif Hegazi

HOM(P)

640

62858

32815

Nil

C.M. Akram

HOM(U)

640

62365

8731737

Nil

Prafull Pandav

SOE

289

62859

8732166

Nil.

M.Vasagam

LOE

289

62613

62536

Nil.

Ahmed Al Hosani

SS (Des)

296

69440

8732771

4491988

Abubaker Kassem

SS

296

69440

Nil.

5461003

Obaid Rashid Hammed Ali

OSE

286

62114

8731869

Nil

Abdalla Al Hashmi

OSE

286

62114

8731834

Nil

Fayez Al-Akbari / K. M.Al Mehairi

Safety Tech

288

62247

Nil

Nil

Suryan Krishnan./Mazen Al Zaabi

Safety Tech

288

62247

Nil

Nil

22

Table 1c - EMERGENCY ORGANISATION
ADNOC

ABUDHABI CRISIS
MANAGEMENT TEAM
(CMT)

For details of linkage to ADNOC CMT see ADGAS Crisis

ADNOC

For details of roles and responsibilities see Crisis Management Manual

CMT

GM

CMT TEAM MEMBERS

Incident Commander
(IC)

INCIDENT
COMMANDER
CENTRE

Operation Section Chief
(OSC)

Safety Officer (SO)

Planning Section Chief
(PSC)

Finance Admin Section
Chief (FASC)

EMRGENCY
SERVICES CONTROL
ROOM

Liaison Information
Officer (LIO)

Operation Safety
Engineer (D)

SOURCE CONTROL
CORDINATOR

CENTRAL CONTROL
BUILDING
Maintenance Support

Head of Shift
Operations (HSO)

OPERATIONS
SUPPORT

senior operators (CCB)

AC (STOREX)
STOREX CONTROL
ROOM

SENIOR OPERATOR
(CCB)

Source Control Team
Leader

Area Controller (P)

Area Controller (U)

Senior Operator (P)

Senior Operator (U)
Field

Fire Rescue Team
Leader

Site Safety Officer
(SSO)

Wardens

INCIDENT SCENE

Safety Technician

Jetty Operator

Area Operator (P)
Trainins 1,2,&3

Senior Operator Field

Senior Marine Operator

Area Operator (U)
Trainins 1,2,&3

23

Sponsor Documents

Or use your account on DocShare.tips

Hide

Forgot your password?

Or register your new account on DocShare.tips

Hide

Lost your password? Please enter your email address. You will receive a link to create a new password.

Back to log-in

Close